Polaris 500 Offroad Vehicle User Manual


 
BODY / STEERING / SUSPENSION
5.29
FOXt REAR SHOCK SERVICE
When performing maintenance on Foxt shocks, use
the Gas Shock Recharging Kit (PN 2200421), as it
contains the necessary valves, pressure gauge, and
fittings to deflate and pressurize shocks.
W ARNING: Foxt shocks contain high pressure
nitrogen gas. Extreme caution must be used while
handling and working with Foxt shocks and related
high pressure service equipment. The pressure must
be released from the shock before disassembly. It is
strongly recommended you wear safety glasses and
ear protection during these procedures.
TIP: Extreme cleanliness is of utmost importance
during all disassembly and reassembly operations.
This prevents dirt or foreign particles from entering the
shock which causes premature failure.
Recommended Service Intervals
Foxt Racing Shocks will perform the best if serviced
at regular intervals:
G Every ride -- Wash and dry the
vehicle and suspension.
G Every 100 hours -- Visually inspect
shock seals
G Every 500 hours or Annually --
Change shock oil and seals.
1. Safety Glasses
2. Latex Gloves
3. Lint Free Towels
4. Assembly Lube (lithium based grease)
5. Loctite #271
6. 12” Tie Wrap (Zip Tie)
7. MAPP Gas or Propane Torch
8. Fox 1.834 TC Seal Kit
9. Fox 5wt. Shock Fluid
10. Fox IFP Depth Setting Tool
11. Fox Seal Installation Bullet (5/8”)
12. Fox Nitrogen Safety Needle
13. 5/8” Shaft Clamps
14. Adjustable Wrench
15. Pin Spanner Wrench (3/16” Pins)
16. 3/32” Hex Key (Allen Wrench)
17. 5/32” Hex Key (Allen Wrench)
18. Scribe or Dental Pick
19. 1/4” Flat Blade Screwdriver
20. #2 Phillips Screwdriver
21. 3/4” Open End Wrench
22. Standard Pliers
23. Small Needle Nose Pliers
24. Snap Ring Pliers
25. Socket
26. Torque Wrench
27. Torque Driver
28. Soft Faced Rubber Mallet
29. Nitrogen Tank w/ Regulator
30. Cleaning Solvent
31. Vice with soft jaws
32. Tape Measure
Special Tools Required:
Body Holding Tool (PN 2871017)
Charging Needle (PN 7052069)
Gas Shock Recharging Kit (PN 2200421)
Foxt Shock IFP Tool (PN 2871351)
Enfocus Software - Customer Support