Filter
Top Products
5.1
Section 5
Fuel System and Governor
5
Section 5
Fuel System and Governor
Description
WARNING: Explosive Fuel!
Gasoline is extremely flammable and its vapors can
explode if ignited. Store gasoline only in approved
containers, in well ventilated, unoccupied buildings,
away from sparks or flames. Do not fill the fuel tank
while the engine is hot or running, since spilled fuel
could ignite if it comes in contact with hot parts or
sparks from ignition. Do not start the engine near
spilled fuel. Never use gasoline as a cleaning agent.
Fuel System Components
The typical fuel system and related components
include the following:
• Fuel Tank
• In-line Fuel Filter
• Fuel Pump
• Carburetor
• Fuel Lines
Operation
The fuel from the tank is moved through the in-line
filter and fuel lines by the fuel pump. On engines not
equipped with a fuel pump, the fuel tank outlet is
located above the carburetor inlet allowing gravity to
feed fuel to the carburetor.
Fuel then enters the carburetor float bowl and is
moved into the carburetor body. There, the fuel is
mixed with air. This fuel-air mixture is then burned in
the engine combustion chamber.
Fuel Recommendations
General Recommendations
Purchase gasoline in small quantities and store
in clean, approved containers. A container with a
capacity of 2 gallons or less with a pouring spout is
recommended. Such a container is easier to handle
and helps eliminate spillage during refueling.
• Do not use gasoline left over from the previous
season, to minimize gum deposits in your fuel
system and to ensure easy starting.
• Do not add oil to the gasoline.
• Do not overfill the fuel tank. Leave room for the
fuel to expand.
Fuel Type
For best results, use only clean, fresh, unleaded
gasoline with a pump sticker octane rating of 87 or
higher. In countries using the Research fuel rating
method, it should be 90 octane minimum.
Unleaded gasoline is recommended, as it leaves less
combustion chamber deposits. Leaded gasoline may
be used in areas where unleaded is not available and
exhaust emissions are not regulated. Be aware
however, that the cylinder head will require more
frequent service.
Gasoline/Alcohol blends
Gasohol (up to 10% ethyl alcohol, 90% unleaded
gasoline by volume) is approved as a fuel for Kohler
engines. Other gasoline/alcohol blends are not
approved.
Gasoline/Ether blends
Methyl Tertiary Butyl Ether (MTBE) and unleaded
gasoline blends (up to a maximum of 15% MTBE by
volume) are approved as a fuel for Kohler engines.
Other gasoline/ether blends are not approved.
Fuel Filter
Most engines are equipped with an in-line fuel filter.
Periodically inspect the filter and replace when dirty
with a genuine Kohler filter.
LV560, LV625, LV675
Go Back