Filter
Top Products
The following abbreviations are used to represent values for Control Module Pin-Out data
I Input SG Sensor Ground S SCP Network V Voltage (DC)
O Output A ACP Network D Serial and Encoded Data Hz Frequency
SS Sensor Supply V C CAN (Network) B+ Battery Voltage kHz Frequency x 1000
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation. THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components
connected and fitted. “Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE: September 2000
Fig. 10.2
COMPONENTS
Component Connector / Type / Color Location / Access
AIR CONDITIONING CONTROL PANEL CC27 / 12-WAY MULTILOCK 040 / BLUE CENTER CONSOLE
CENTER CONSOLE SWITCH PACK CC1 / 16-WAY FORD IDC S.U. / BLACK CENTER CONSOLE SWITCH PACK
CIGAR LIGHTER – FRONT CA74 / 3-WAY MULTILOCK 070 / WHITE CENTER CONSOLE ASSEMBLY
CIGAR LIGHTER – REAR CA75 / 2-WAY AMP / METALLIC REAR CENTER CONSOLE VENT
CA76 / 1-WAY LUCAR POSILOCK MKI / BLACK
ANALOG CLOCK FC38 / 6-WAY AMP MICRO QUAD LOCK / BLACK CENTER AIR VENT
CRUISE CONTROL ON / OFF SWITCH CC20 / 10-WAY AMP MICRO QUAD LOCK / NATURAL CENTER CONSOLE ASSEMBLY
DIMMER CONTROL SC11 / 6-WAY MULTILOCK 070 / WHITE COLUMN SWITCHGEAR
DIMMER MODULE FC23 / 12-WAY MULTILOCK 040 / BLACK BELOW INSTRUMENT PACK
FASCIA SWITCH PACK FC14 / 6-WAY JAE IL-AG5 / GREEN FASCIA SWITCH PACK
FOG LAMP SWITCHES FC3 / 10-WAY AMP MICRO QUAD LOCK / NATURAL FASCIA / OUTBOARD OF STEERING COLUMN
GEAR SELECTOR ILLUMINATION MODULE CC14 / 10-WAY MULTILOCK 070 / WHITE CENTER CONSOLE ASSEMBLY
INSTRUMENT PACK FC24 / 26-WAY AMP MICRO QUAD LOCK / BLACK FASCIA
FC25 / 26-WAY AMP MICRO QUAD LOCK / YELLOW
LIGHTING STALK (COLUMN SWITCHGEAR) SC2 / 10-WAY MULTILOCK 070 / YELLOW COLUMN SWITCHGEAR HARNESS /
ADJACENT TO STEERING COLUMN MOTOR
MODE SWITCH (TRANSMISSION) CC4 / 10-WAY AMP MICRO QUAD LOCK / BLACK CENTER CONSOLE ASSEMBLY
RADIO / CASSETTE HEAD UNIT CA3 / COAXIAL CONNECTOR CENTER CONSOLE
IC10 / 20-WAY MULTILOCK 070 / WHITE
IC11 / 26-WAY AMP MICRO QUAD LOCK / YELLOW
IC19 / 8-WAY ALPINE / BLACK
ROOF CONSOLE CA53 / 8-WAY MULTILOCK 040 / BLACK ROOF CONSOLE
SPLICE HEADER – CA224 CA224 / 20-WAY SUMITOMO SPLICE HEADER / GREEN LH HEELBOARD / HEELBOARD COVER
SWITCH PACK – DRIVER DOOR DD1 / 26-WAY AMP MICRO QUAD LOCK / YELLOW DOOR TRIM PANEL
SWITCH PACK – DRIVER REAR DOOR RD1 / 5-WAY JAE IL-AG5 / GREEN DOOR TRIM PANEL
SWITCH PACK – PASSENGER DOOR PD1 / 5-WAY JAE IL-AG5 / GREEN DOOR TRIM PANEL
SWITCH PACK – PASSENGER REAR DOOR RP1 / 5-WAY JAE IL-AG5 / GREEN DOOR TRIM PANEL
TRIP COMPUTER SWITCH PACK FC27 / 10-WAY AMP MICRO QUAD LOCK / BLACK FASCIA
HARNESS-TO-HARNESS CONNECTORS
Connector Type / Color Location / Access
CA8 20-WAY MULTILOCK 070 / WHITE DRIVER ‘A’ POST / DOOR HARNESS GAITER
CA11 20-WAY MULTILOCK 070 / WHITE PASSENGER ‘A’ POST / DOOR HARNESS GAITER
CA14 6-WAY MULTILOCK 070 / WHITE DRIVER ‘B/C’ POST / DOOR HARNESS GAITER
CA16 6-WAY MULTILOCK 070 / WHITE PASSENGER ‘B/C’ POST / DOOR HARNESS GAITER
CA19 20-WAY MULTILOCK 070 / YELLOW LH ‘A’ POST CONNECTOR MOUNTING BRACKET / LOWER ‘A’ POST FINISHER
CA27 10-WAY MULTILOCK 070 / WHITE BELOW PASSENGER SEAT
CA45 4-WAY MULTILOCK 070 / WHITE PASSENGER ‘B/C’ POST / DOOR HARNESS GAITER
CA46 4-WAY MULTILOCK 070 / WHITE DRIVER ‘B/C’ POST / DOOR HARNESS GAITER
FC5 54-WAY THROUGH PANEL CONNECTOR / GREY BELOW DRIVER SIDE AIR VENT / COIN TRAY
FC7 20-WAY MULTILOCK 070 / YELLOW ABOVE DIMMER MODULE / COIN TRAY
SC3 12-WAY MULTILOCK 070 / GREY ADJACENT TO STEERING COLUMN MOTOR
SP25 10-WAY MULTILOCK 070 / WHITE BEHIND PASSENGER SEAT BACK FINISHER
GROUNDS
Ground Location / Type
CA30L EYELET (PAIR) – LH ‘A’ POST GROUND SCREW
CA33L EYELET (PAIR) – RH ‘A’ POST GROUND SCREW
CA36L EYELET (PAIR) – LH ‘A’ POST GROUND SCREW
CA47L EYELET (PAIR) – DRIVE SHAFT TUNNEL GROUND STUD – RH SIDE
CA47R EYELET (PAIR) – DRIVE SHAFT TUNNEL GROUND STUD – RH SIDE
CC2R EYELET (PAIR) – DRIVE SHAFT TUNNEL GROUND STUD – LH SIDE
CC3L EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
CC3R EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
FC17R EYELET (PAIR) – EMS BULKHEAD GROUND STUD
FC29L EYELET (PAIR) – LH BULKHEAD GROUND STUD / CABIN SIDE
FC29R EYELET (PAIR) – LH BULKHEAD GROUND STUD / CABIN SIDE
IC8 EYELET (SINGLE) – RADIO GROUND STUD / REARWARD OF GEAR SELECTOR ASSEMBLY
FOR CONTROL MODULE PIN OUT INFORMATION, UNFOLD PAGE TO LEFT.
CONTROL MODULE PIN OUT INFORMATION
DIMMER MODULE
Pin Description Active Inactive
O FC23-1 INSTRUMENT PACK ILLUMINATION BULB SUPPLY B+ (LIGHTS ON) GROUND
O FC23-2 INSTRUMENT PACK ILLUMINATION BULB SUPPLY B+ (LIGHTS ON) GROUND
I FC23-3 IGNITION SWITCHED GROUND SUPPLY GROUND
I FC23-4 SIDE LAMPS ON REQUEST GROUND
I FC23-5 DIMMER POTENTIOMETER FEEDBACK VOLTAGE 1.3 V = DIM; 4 V = BRIGHT
O FC23-6 DIMMER POTENTIOMETER REFERENCE GROUND GROUND GROUND
O FC23-7 GENERAL ILLUMINATION BULB SUPPLY B+ (LIGHTS ON) GROUND
O FC23-8 GENERAL ILLUMINATION BULB SUPPLY B+ (LIGHTS ON) GROUND
I FC23-9 GROUND SUPPLY GROUND GROUND
I FC23-10 BATTERY POWER SUPPLY B+ B+
I FC23-11 BATTERY POWER SUPPLY B+ B+
O FC23-12 DIMMER POTENTIOMETER REFERENCE VOLTAGE 4 V 0 V
INSTRUMENT PACK
Pin Description Active Inactive
I FC24-16 GROUND GROUND GROUND
I FC24-6 ILLUMINATION SUPPLY B+ GROUND
I FC25-21 DIMMER OVERRIDE GROUND B+