Filter
Top Products
The following abbreviations are used to represent values for Control Module Pin-Out data
I Input SG Sensor Ground S SCP Network V Voltage (DC)
O Output A ACP Network D Serial and Encoded Data Hz Frequency
SS Sensor Supply V C CAN (Network) B+ Battery Voltage kHz Frequency x 1000
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation. THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components
connected and fitted. “Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE: September 2000
Fig. 06.3
COMPONENTS
Component Connector / Type / Color Location / Access
ACCELEROMETER – FRONT LATERAL EM28 / 3-WAY AMP MICRO QUAD LOCK / BLACK ENGINE COMPARTMENT / CONTROL MODULE ENCLOSURE
ACCELEROMETER – FRONT VERTICAL EM4 / 3-WAY AMP MICRO QUAD LOCK / BLACK ENGINE COMPARTMENT / CONTROL MODULE ENCLOSURE
ACCELEROMETER – REAR VERTICAL BT7 / 3-WAY AMP MICRO QUAD LOCK / BLACK BELOW FUEL TANK / TRUNK CARPET
ADAPTIVE DAMPING CONTROL MODULE EM68 / 35-WAY AMP JUNIOR POWER TIMER / BLACK ADJACENT TO PASSENGER SIDE BLOWER /
GLOVE BOX ASSEMBLY
BRAKE SWITCH CC40 / 4-WAY MULTILOCK 070 / WHITE ADJACENT TO THE BRAKE PEDAL MOUNTING ASSEMBLY
DAMPER SOLENOID – LH FRONT EM64 / 2-WAY DELPHI / REINSHAGEN / BLACK ENGINE COMPARTMENT / LEFT HAND SIDE
DAMPER SOLENOID – LH REAR LA1 / 2-WAY DELPHI / REINSHAGEN / BLACK REAR AXLE / LH REAR DAMPER SOLENOID
DAMPER SOLENOID – RH FRONT EM65 / 2-WAY DELPHI / REINSHAGEN / BLACK ENGINE COMPARTMENT / RIGHT HAND SIDE
DAMPER SOLENOID – RH REAR RA1 / 2-WAY DELPHI / REINSHAGEN / BLACK REAR AXLE / RH REAR DAMPER SOLENOID
HARNESS-TO-HARNESS CONNECTORS
Connector Type / Color Location / Access
BT4 54-WAY THROUGH PANEL / GREY BELOW PARCEL SHELF / TRUNK / REAR BULKHEAD / RH SIDE
CA9 4-WAY MULTILOCK 070 / WHITE BELOW REAR SEAT CUSHION
CA19 20-WAY MULTILOCK 070 / YELLOW LH ‘A’ POST CONNECTOR MOUNTING BRACKET / LOWER ‘A’ POST FINISHER
CA29 4-WAY MULTILOCK 070 / WHITE BELOW REAR SEAT CUSHION
EM1 12-WAY AUGAT 1.6 / BLACK ENGINE COMPARTMENT / ADJACENT TO ABS PUMP
EM2 20-WAY MULTILOCK 070 / GREY PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
FC1 54-WAY THROUGH PANEL CONNECTOR / GREY BELOW PASSENGER SIDE AIR VENT / GLOVE BOX ASSEMBLY
FC5 54-WAY THROUGH PANEL CONNECTOR / GREY BELOW DRIVER SIDE AIR VENT / COIN TRAY
LF3 54-WAY THROUGH PANEL CONNECTOR / GREY LH ‘A’ POST / LOWER ‘A’ POST FINISHER
GROUNDS
Ground Location / Type
EM17 EYELET (SINGLE) – EMS BULKHEAD GROUND STUD
FOR CONTROL MODULE PIN OUT INFORMATION, UNFOLD PAGE TO LEFT.
CONTROL MODULE PIN OUT INFORMATION
ADAPTIVE DAMPING CONTROL MODULE
Pin Description Active Inactive
O EM68-1 INSTRUMENT PACK ADAPTIVE DAMPENING MIL GROUND B+
O EM68-3 ACCELEROMETER COMMON GROUND SUPPLY GROUND GROUND
D EM68-10 SERIAL COMMUNICATIONS
I EM68-11 IGNITION SWITCHED POWER SUPPLY B+ GROUND
O EM68-13 LH REAR DAMPER BATTERY POWER SUPPLY B+ B+
O EM68-14 RH FRONT DAMPER BATTERY POWER SUPPLY B+ B+
O EM68-15 RH REAR DAMPER BATTERY POWER SUPPLY B+ B+
I EM68-18 GROUND GROUND GROUND
I EM68-20 FRONT LATERAL ACCELEROMETER FEEDBACK < 0.2 V OR > 4.8 V 2.3 – 2.7 V = HARD
I EM68-21 FRONT VERTICAL ACCELEROMETER FEEDBACK < 0.2 V OR > 4.8 V 2.3 – 2.7 V = HARD
I EM68-22 REAR VERTICAL ACCELEROMETER FEEDBACK < 0.2 V OR > 4.8 V 2.3 – 2.7 V = HARD
I EM68-24 VEHICLE SPEED SIGNAL 22 Hz @ 10 MPH (16 KM / H); 44 Hz @ 20 MPH (32 KM / H) @ B+
O EM68-25 ACCELEROMETER COMMON VOLTAGE SUPPLY 5 V 5 V
I EM68-26 BRAKE SWITCH GROUND B+
I EM68-27 BATTERY POWER SUPPLY B+ B+
D EM68-28 SERIAL COMMUNICATIONS
O EM68-30 LH FRONT DAMPER BATTERY POWER SUPPLY B+ B+
O EM68-31 LH FRONT DAMPER GROUND B+
O EM68-32 LH REAR DAMPER GROUND B+
O EM68-33 RH FRONT DAMPER GROUND B+
O EM68-34 RH REAR DAMPER GROUND B+