Filter
Top Products
The following abbreviations are used to represent values for Control Module Pin-Out data
I Input SG Sensor Ground S SCP Network V Voltage (DC)
O Output A ACP Network D Serial and Encoded Data Hz Frequency
SS Sensor Supply V C CAN (Network) B+ Battery Voltage kHz Frequency x 1000
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation. THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components
connected and fitted. “Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE: September 2000
Fig. 09.2
COMPONENTS
Component Connector / Type / Color Location / Access
BODY PROCESSOR MODULE FC15 / 14-WAY AMP EEEC / GREY BULKHEAD / BEHIND GLOVE BOX
BRAKE SWITCH CC40 / 4-WAY MULTILOCK 070 / WHITE ADJACENT TO THE BRAKE PEDAL MOUNTING ASSEMBLY
CENTER CONSOLE SWITCH PACK CC1 / 16-WAY FORD IDC S.U. / BLACK CENTER CONSOLE SWITCH PACK
DIODE (BT40) – NUMBER PLATE BT40 / 2-WAY DIODE MODULE ASSEMBLY ADJACENT TO BATTERY / BATTERY COVER
FOG LAMP SWITCHES FC3 / 10-WAY AMP MICRO QUAD LOCK / NATURAL FASCIA / OUTBOARD OF STEERING COLUMN
FUSE BOX – TRUNK BT10 / 10-WAY U.T.A. FUSE BOX / NATURAL TRUNK ELECTRICAL CARRIER
BT11 / 10-WAY U.T.A. FUSE BOX / BLACK
BT12 / 10-WAY U.T.A. FUSE BOX / GREEN
BT13 / 10-WAY U.T.A. FUSE BOX / BLUE
BT64 / EYELET
HIGH MOUNTED STOP LAMP CA35 / 2-WAY YAZAKI / NATURAL BACKLIGHT
INSTRUMENT PACK FC24 / 26-WAY AMP MICRO QUAD LOCK / BLACK FASCIA
FC25 / 26-WAY AMP MICRO QUAD LOCK / YELLOW
LIGHTING STALK (COLUMN SWITCHGEAR) SC2 / 10-WAY MULTILOCK 070 / YELLOW COLUMN SWITCHGEAR HARNESS /
ADJACENT TO STEERING COLUMN MOTOR
NUMBER PLATE LAMP – LH BT27 / 2-WAY AMP POSILOCK II / BLACK BEHIND TRUNK LID LINER
NUMBER PLATE LAMP – RH BT26 / 2-WAY AMP POSILOCK II / BLACK BEHIND TRUNK LID LINER
REAR SIDE MARKER – LH (NAS ONLY) BT29 / 2-WAY REINSHAGEN / VOLKSWAGEN / BLACK TRUNK LH SIDE / TRUNK CARPET
REAR SIDE MARKER – RH (NAS ONLY) BT31 / 2-WAY REINSHAGEN / VOLKSWAGEN / BLACK TRUNK RH SIDE / TRUNK CARPET
SECURITY AND LOCKING CONTROL MODULE BT1 / 16-WAY FORD 2.8 TIMER / BLACK BELOW TRUNK FUSE BOX
BT2 / 26-WAY FORD IDC / BLACK
BT6 / 2-WAY MINI UHF / METALLIC
TAIL LAMP UNIT – LH BT51 / 7-WAY FRAM – FORD 2.8 TIMER / BLACK TRUNK LH SIDE / REAR LAMP COVER
TAIL LAMP UNIT – RH BT50 / 7-WAY FRAM – FORD 2.8 TIMER / BLACK TRUNK RH SIDE / REAR LAMP COVER
TRAILER CONNECTOR BT32 / 14-WAY MULTILOCK 070 / YELLOW ABOVE TRUNK FUSE BOX
RELAYS
Relay Case Color Connector / Color Location / Access
STOP LAMP RELAY BROWN BUS RELAY #5, TRUNK FUSE BOX / TRUNK
SIDE MARKER AND NUMBER PLATE LAMP RELAY BROWN BUS RELAY #3, TRUNK FUSE BOX / TRUNK
HARNESS-TO-HARNESS CONNECTORS
Connector Type / Color Location / Access
BT4 54-WAY THROUGH PANEL / GREY BELOW PARCEL SHELF / TRUNK / REAR BULKHEAD / RH SIDE
CA19 20-WAY MULTILOCK 070 / YELLOW LH ‘A’ POST CONNECTOR MOUNTING BRACKET / LOWER ‘A’ POST FINISHER
FC1 54-WAY THROUGH PANEL CONNECTOR / GREY BELOW PASSENGER SIDE AIR VENT / GLOVE BOX ASSEMBLY
FC5 54-WAY THROUGH PANEL CONNECTOR / GREY BELOW DRIVER SIDE AIR VENT / COIN TRAY
FC7 20-WAY MULTILOCK 070 / YELLOW ABOVE DIMMER MODULE / COIN TRAY
GROUNDS
Ground Location / Type
BT20 EYELET (SINGLE) – TRUNK / RH REAR GROUND STUD
BT21L EYELET (PAIR) – TRUNK / RH REAR GROUND STUD
BT22L* EYELET (PAIR) – TRUNK / RH CENTER GROUND STUD (*PREMIUM ICE)
BT24* EYELET (SINGLE) – TRUNK / RH CENTER GROUND STUD (*STANDARD ICE)
CA31L EYELET (PAIR) – RH DRIVE SHAFT TUNNEL GROUND STUD
CC3L EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
CC3R EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
FC17L EYELET (PAIR) – EMS BULKHEAD GROUND STUD
FC17R EYELET (PAIR) – EMS BULKHEAD GROUND STUD
FOR CONTROL MODULE PIN OUT INFORMATION, UNFOLD PAGE TO LEFT.
CONTROL MODULE PIN OUT INFORMATION
BODY PROCESSOR MODULE
Pin Description Active Inactive
I FC15-12 REAR FOG LAMP REQUEST GROUND B+
I FC15-15 IGNITION SWITCHED GROUND GROUND B+
I FC15-16 SIDE LAMP REQUEST GROUND B+
O FC15-28 RH TAIL LAMP SUPPLY B+ GROUND
I FC15-41 STARTER ENGAGE REQUEST GROUND (CRANKING) B+
O FC15-44 REAR FOG LAMP STATUS GROUND B+
O FC15-49 TRAILER RH DI LAMP SUPPLY B+ (PULSED) GROUND
O FC15-50 LH DI LAMP SUPPLY B+ (PULSED) GROUND
O FC15-54 LH TAIL LAMP SUPPLY B+ GROUND
I FC15-59 HAZARD LAMP REQUEST GROUND (MOMENTARY) B+
I FC15-61 RH DI REQUEST GROUND B+
O FC15-75 TRAILER LH DI LAMP SUPPLY B+ (PULSED) GROUND
O FC15-76 RH DI LAMP SUPPLY B+ (PULSED) GROUND
I FC15-79 BATTERY SUPPLY VOLTAGE B+ B+
I FC15-80 BATTERY SUPPLY VOLTAGE B+ B+
S FC15-84 SCP NETWORK 2 – 1600 Hz
S FC15-85 SCP NETWORK 2 – 1600 Hz
I FC15-88 LH DI REQUEST GROUND B+
O FC15-95 SIDE MARKER & NUMBER PLATE LAMP RELAY ACTIVATE GROUND B+
O FC15-96 HAZARD LAMP STATUS GROUND (PULSE) B+
I FC15-104 BATTERY SUPPLY VOLTAGE B+ B+
INSTRUMENT PACK
Pin Description Active Inactive
C FC24-11 CAN NETWORK 15 – 1500 Hz
S FC24-13 SCP NETWORK 2 – 1600 Hz
S FC24-14 SCP NETWORK 2 – 1600 Hz
C FC24-24 CAN NETWORK 15 – 1500 Hz
SECURITY AND LOCKING CONTROL MODULE
Pin Description Active Inactive
O BT1-3 RH STOP LAMP SUPPLY B+ GROUND
O BT1-4 REAR FOG LAMP SUPPLY B+ GROUND
O BT1-5 REVERSE LAMP SUPPLY B+ GROUND
I BT1-6 BATTERY SUPPLY B+ B+
O BT1-7 SPLIT CHARGE CONTROL
S BT1-8 SCP NETWORK 2 – 1600 Hz
O BT1-9 LH STOP LAMP SUPPLY B+ GROUND
I BT1-13 LOGIC GROUND GROUND GROUND
I BT1-14 LOGIC GROUND GROUND GROUND
S BT1-16 SCP NETWORK 2 – 1600 Hz
I BT2-1 BRAKE SWITCH STATUS GROUND (BRAKE ON) B+
I BT2-6 TRAILER CONNECTION STATUS GROUND (TRAILER PRESENT) B+ (NO TRAILER)
NOTE: Refer to the Appendix at the rear of this book for CAN and SCP Network messages.