Filter
Top Products
The following abbreviations are used to represent values for Control Module Pin-Out data
I Input SG Sensor Ground S SCP Network V Voltage (DC)
O Output A ACP Network D Serial and Encoded Data Hz Frequency
SS Sensor Supply V C CAN (Network) B+ Battery Voltage kHz Frequency x 1000
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation. THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components
connected and fitted. “Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE: September 2000
Fig. 13.2
COMPONENTS
Component Connector / Type / Color Location / Access
BODY PROCESSOR MODULE FC15 / 14-WAY AMP EEEC / GREY BULKHEAD / BEHIND GLOVE BOX
CENTRAL LOCKING SWITCH CC1 / 16-WAY FORD IDC S.U. / BLACK CENTER CONSOLE SWITCH PACK
(CENTER CONSOLE SWITCH PACK)
DOOR CONTROL MODULE – DRIVER DD10 / 22-WAY FORD 2.8 TIMER / BLUE DOOR CASING / TRIM PANEL
DD11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR CONTROL MODULE – DRIVER REAR RD10 / 22-WAY FORD 2.8 TIMER / BLUE DOOR CASING / TRIM PANEL
RD11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR CONTROL MODULE – PASSENGER PD10 / 22-WAY FORD 2.8 TIMER / BLUE DOOR CASING / TRIM PANEL
PD11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR CONTROL MODULE – PASSENGER REAR RP10 / 22-WAY FORD 2.8 TIMER / BLUE DOOR CASING / TRIM PANEL
RP11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR LOCK ACTUATOR – DRIVER DD3 / 13-WAY ECONOSEAL III LC / BLACK DOOR CASING / TRIM PANEL
DOOR LOCK ACTUATOR – DRIVER REAR RD3 / 6-WAY ECONOSEAL III LC / BLACK DOOR CASING / TRIM PANEL
DOOR LOCK ACTUATOR – PASSENGER PD3 / 13-WAY ECONOSEAL III LC / BLACK DOOR CASING / TRIM PANEL
DOOR LOCK ACTUATOR – PASSENGER REAR RP3 / 6-WAY ECONOSEAL III LC / BLACK DOOR CASING / TRIM PANEL
DOOR LOCK SWITCHES – DRIVER DD3 / 13-WAY ECONOSEAL III LC / BLACK DOOR CASING / TRIM PANEL
DOOR SWITCH – DRIVER DD3 / 13-WAY ECONOSEAL III LC / BLACK DOOR CASING / TRIM PANEL
DOOR SWITCH – DRIVER REAR RD3 / 6-WAY ECONOSEAL III LC / BLACK DOOR CASING / TRIM PANEL
DOOR SWITCH – PASSENGER PD3 / 13-WAY ECONOSEAL III LC / BLACK DOOR CASING / TRIM PANEL
DOOR SWITCH – PASSENGER REAR RP3 / 6-WAY ECONOSEAL III LC / BLACK DOOR CASING / TRIM PANEL
FUEL FILLER FLAP LOCK ACTUATOR BT16 / 2-WAY LABINAL / NATURAL TRUNK / LH FRONT
IGNITION SWITCH (KEY-IN SWITCH) FC4 / 8-WAY MULTILOCK 070 / WHITE STEERING COLUMN
KEY FOB ANTENNA BT33 / 1-WAY COAXIAL CONNECTOR / BLACK TOP OF BACKLIGHT
NOT-IN-PARK MICROSWITCH CC13 / 3-WAY MULTILOCK 070 / WHITE CENTER CONSOLE ASSEMBLY
SECURITY AND LOCKING CONTROL MODULE BT1 / 16-WAY FORD 2.8 TIMER / BLACK BELOW TRUNK FUSE BOX
BT2 / 26-WAY FORD IDC / BLACK
BT6 / 2-WAY MINI UHF / METALLIC
SPLICE HEADER – CA223 CA223 / 20-WAY SUMITOMO SPLICE HEADER / BLACK RH HEELBOARD / HEELBOARD COVER
TRUNK RELEASE ACTUATOR BT43 / 2-WAY LABINAL / BROWN BEHIND TRUNK LID LINER
TRUNK RELEASE SWITCH BT42 / 2-WAY MULTILOCK 040 / GREEN BEHIND TRUNK LID LINER
TRUNK RELEASE SWITCH FC14 / 6-WAY JAE IL-AG5 / GREEN FASCIA SWITCH PACK
(FASCIA SWITCH PACK)
TRUNK SWITCH BT41 / 2-WAY AUGAT 1.6 / BLACK BEHIND TRUNK LID LINER
VALET SWITCH CC1 / 16-WAY FORD IDC S.U. / BLACK CENTER CONSOLE SWITCH PACK
(CENTER CONSOLE SWITCH PACK)
RELAYS
Relay Case Color Connector / Color Location / Access
DOOR LOCKING RELAY BLACK CA50 / BLACK LH HEELBOARD RELAYS / HEELBOARD COVER
FUEL FILLER FLAP LOCK RELAY BLACK BT23 / BLACK TRUNK RELAYS / TRUNK
FUEL FILLER FLAP UNLOCK RELAY BLACK BT23 / BLACK TRUNK RELAYS / TRUNK
HARNESS-TO-HARNESS CONNECTORS
CONNector Type / Color Location / Access
BT4 54-WAY THROUGH PANEL / GREY BELOW PARCEL SHELF / TRUNK / REAR BULKHEAD / RH SIDE
CA8 20-WAY MULTILOCK 070 / WHITE DRIVER ‘A’ POST / DOOR HARNESS GAITER
CA10 8-WAY MULTILOCK 070 / YELLOW DRIVER ‘A’ POST / DOOR HARNESS GAITER
CA11 20-WAY MULTILOCK 070 / WHITE PASSENGER ‘A’ POST / DOOR HARNESS GAITER
CA11 20-WAY MULTILOCK 070 / WHITE PASSENGER ‘A’ POST / DOOR HARNESS GAITER
CA12 8-WAY MULTILOCK 070 / YELLOW PASSENGER ‘A’ POST / DOOR HARNESS GAITER
CA14 6-WAY MULTILOCK 070 / WHITE DRIVER ‘B/C’ POST / DOOR HARNESS GAITER
CA16 6-WAY MULTILOCK 070 / WHITE PASSENGER ‘B/C’ POST / DOOR HARNESS GAITER
CA45 4-WAY MULTILOCK 070 / WHITE PASSENGER ‘B/C’ POST / DOOR HARNESS GAITER
CA46 4-WAY MULTILOCK 070 / WHITE DRIVER ‘B/C’ POST / DOOR HARNESS GAITER
FC1 54-WAY THROUGH PANEL CONNECTOR / GREY BELOW PASSENGER SIDE AIR VENT / GLOVE BOX ASSEMBLY
FC7 20-WAY MULTILOCK 070 / YELLOW ABOVE DIMMER MODULE / COIN TRAY
GROUNDS
Ground Location / Type
BT22L* EYELET (PAIR) – TRUNK / RH CENTER GROUND STUD (*PREMIUM ICE)
BT24* EYELET (SINGLE) – TRUNK / RH CENTER GROUND STUD (*STANDARD ICE)
BT28L EYELET (PAIR) – TRUNK / RH CENTER GROUND STUD
BT34 EYELET (SINGLE) – KEY FOB ANTENNA GROUND / BACKLIGHT / CENTER
CA30R EYELET (PAIR) – LH ‘A’ POST GROUND SCREW
CA31L EYELET (PAIR) – RH DRIVE SHAFT TUNNEL GROUND STUD
CA33L EYELET (PAIR) – RH ‘A’ POST GROUND SCREW
CA33R EYELET (PAIR) – RH ‘A’ POST GROUND SCREW
CA36L EYELET (PAIR) – LH ‘A’ POST GROUND SCREW
CA36R EYELET (PAIR) – LH ‘A’ POST GROUND SCREW
CC3L EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
CC3R EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
FC17L EYELET (PAIR) – EMS BULKHEAD GROUND STUD
FOR CONTROL MODULE PIN OUT INFORMATION, UNFOLD PAGE TO LEFT.
CONTROL MODULE PIN OUT INFORMATION
BODY PROCESSOR MODULE
Pin Description Active Inactive
I FC15-5 TRUNK RELEASE REQUEST GROUND (MOMENTARY) B+
I FC15-15 IGNITION SWITCHED GROUND GROUND B+
I FC15-32 IGNITION SWITCHED GROUND GROUND B+
I FC15-33 IGNITION SWITCHED GROUND GROUND B+
I FC15-41 STARTER ENGAGE REQUEST GROUND (CRANKING) B+
I FC15-55 VALET REQUEST GROUND (MOMENTARY) B+
I FC15-58 NOT IN PARK MICROSWITCH STATUS GROUND (PARK) B+ (NOT IN PARK)
I FC15-63 CENTRAL LOCKING REQUEST GROUND (MOMENTARY) B+
I FC15-67 KEY IN IGNITION GROUND (KEY IN) B+ (KEY OUT)
O FC15-71 DOOR LOCKING RELAY ACTIVATE GROUND (PULSE) B+
I FC15-80 BATTERY SUPPLY VOLTAGE B+ B+
S FC15-84 SCP NETWORK 2 – 1600 Hz
S FC15-85 SCP NETWORK 2 – 1600 Hz
DRIVER DOOR CONTROL MODULE
Pin Description Active Inactive
I DD10-1 BATTERY POWER SUPPLY B+ B+
O DD10-5 DRIVERS DOOR LOCK ACTUATOR MOTOR UNLOCK B+ GROUND
I DD10-8 LOGIC GROUND GROUND GROUND
S DD10-9 SCP NETWORK 2 – 1600 Hz
S DD10-16 SCP NETWORK 2 – 1600 Hz
I DD10-17 POWER GROUND GROUND GROUND
I DD11-4 DRIVER DOOR LOCK BARREL UNLOCK REQUEST B+ (MOMENTARY) GROUND
I DD11-12 DRIVER DOOR LOCK BARREL LOCK REQUEST B+ (MOMENTARY) GROUND
I DD11-20 DRIVER DOOR SWITCH GROUND (DOOR OPEN) B+
DRIVER REAR DOOR CONTROL MODULE
Pin Description Active Inactive
I RD10-1 BATTERY POWER SUPPLY B+ B+
O RD10-5 DRIVER REAR DOOR LOCK ACTUATOR MOTOR UNLOCK B+ GROUND
I RD10-8 LOGIC GROUND GROUND GROUND
S RD10-9 SCP NETWORK 2 – 1600 Hz
S RD10-16 SCP NETWORK 2 – 1600 Hz
I RD10-17 POWER GROUND GROUND GROUND
I RD10-19 MODULE IDENTIFICATION GROUND GROUND
I RD11-7 MODULE IDENTIFICATION GROUND GROUND
I RD11-20 DRIVER REAR DOOR SWITCH GROUND (DOOR OPEN) B+
PASSENGER DOOR CONTROL MODULE
Pin Description Active Inactive
I PD10-1 BATTERY POWER SUPPLY B+ B+
O PD10-5 PASSENGER DOOR LOCK ACTUATOR MOTOR UNLOCK B+ GROUND
I PD10-8 LOGIC GROUND GROUND GROUND
S PD10-9 SCP NETWORK 2 – 1600 Hz
S PD10-16 SCP NETWORK 2 – 1600 Hz
I PD10-17 POWER GROUND GROUND GROUND
I PD11-20 PASSENGER DOOR SWITCH GROUND (DOOR OPEN) B+
PASSENGER REAR DOOR CONTROL MODULE
Pin Description Active Inactive
I RP10-1 BATTERY POWER SUPPLY B+ B+
O RP10-5 PASSENGER REAR DOOR LOCK ACTUATOR MOTOR UNLOCK B+ GROUND
I RP10-8 LOGIC GROUND GROUND GROUND
S RP10-9 SCP NETWORK 2 – 1600 Hz
S RP10-16 SCP NETWORK 2 – 1600 Hz
I RP10-17 POWER GROUND GROUND GROUND
I RP11-20 PASSENGER REAR DOOR SWITCH GROUND (DOOR OPEN) B+
SECURITY AND LOCKING CONTROL MODULE
Pin Description Active Inactive
O BT1-1 TRUNK RELEASE ACTUATOR ACTIVATE B+ (PULSE) GROUND
O BT1-2 FUEL FILLER FLAP UNLOCK RELAY ACTIVATE B+ (PULSE) GROUND
S BT1-8 SCP NETWORK 2 – 1600 Hz
O BT1-10 FUEL FILLER FLAP LOCK RELAY ACTIVATE B+ GROUND
I BT1-13 LOGIC GROUND GROUND GROUND
I BT1-14 LOGIC GROUND GROUND GROUND
I BT1-15 BATTERY POWER SUPPLY B+ B+
S BT1-16 SCP NETWORK 2 – 1600 Hz
I BT2-3 TRUNK RELEASE REQUEST GROUND (MOMENTARY) B+
I BT2-5 TRUNK SECURITY SWITCH STATUS GROUND (INTRUSION) B+ (SECURE)
I BT2-7 DRIVER DOOR LOCK STATUS
I BT2-19 PASSENGER DOOR LOCK STATUS
I BT6-1 KEY FOB ANTENNA
I BT6-2 KEY FOB ANTENNA SHIELD GROUND GROUND
NOTE: Refer to the Appendix at the rear of this book for CAN and SCP Network messages.