Filter
Top Products
13
XJ Series 2001
DATE OF ISSUE: September 2000
16
50 88
749
549
50 63
II II
EE
14
II E
Fig. 01.1Fig. 01.1 Fig. 01.2 Fig. 01.3 Fig. 01.4 Fig. 01.5 Fig. 02.1
I
O
+
–
A
C
S
D
1
19
I
Input
Output
Sensor Supply V ACP
CAN
SCP
Serial and Encoded Data
VARIANT:
VIN RANGE:
DATE OF ISSUE:
F20645
➞
September 2000
XJ Series 2001
Sensor Ground
FC15-39
FC15-73
FC15-7
O
I
FC15-41
I
RW
FC15-80
N
13
III
II
I
FC4-1
FC4-3
FC4-2
WU
RW
WR
1
FC4-5
BK
FCS7
FC17L
BK
250A x 2
BT65
B
BT67 BT66 BT60 BT63
BT61
BT62
R
R
R
250A
R
ST6
R
ST5
01.1
01.1
CC21-3 CC21-1
EM82-2
I
02.1
02.1
BK
BK
CCS5
CC3R
RU
GO
EM2-8
GO
EMS28
GO
GO
WR
NW
W
79
45
II
WR
EM60-2
ST2
ST3
R
B
6
ST4
AN2
B
AN1
AN3-1
AN3-2
B
R
PI50-2
PI50-1
Y
38
II
WG
YY
PI1-11EM3-7
08.1
WR
R
ST1
GO
W
FC22-16
EM82-15
W
Y
EM82-16
Y
FC22-17
D D
D
Y
D
EM2-15
EM2-13
Y
FCS30
D
B+
YB
FC22-9
D
FC15-92
YB
D
YR
FC22-11
D
FC15-21
YR
D
EM50
3
1
5
2
WU
PI2-12
FC7-3
RU
EM81-12
RU
05.1
I
Battery, Starter, Generator: AJ27 N/A
Battery, Starter, Generator: AJ27 N/A Fig 03.1
BATTERY HIGH POWER
PROTECTION MODULE
FALSE BULKHEAD
STUD CONNECTOR
IGNITION SWITCH
(III)
NEUTRAL
SWITCH
PARK, NEUTRAL
(CIRCUIT CONTINUED)
ENGINE
START
FUEL PUMP
CONTROL
AND
IGNITION
SECURITY
ACKNOWLEDGE
O.K. TO START
ENGINE CONTROL
MODULE
INSTRUMENT PACK: CHARGE INDICATOR
(CIRCUIT CONTINUED)
SUPPRESSION
MODULE
ENGINE
CRANKING
CONTROL
LOGIC
POWER
BODY PROCESSOR
MODULE
SECURITY
ACKNOWLEDGE
O.K. TO START
KEY TRANSPONDER MODULE
REGULATOR
GENERATOR
STARTER MOTOR
STARTER RELAY
AJ27 N/A Vehicles
The following abbreviations are used to represent values for Control Module Pin-Out data
I Input SG Sensor Ground S SCP Network V Voltage (DC)
O Output A ACP Network D Serial and Encoded Data Hz Frequency
SS Sensor Supply V C CAN (Network) B+ Battery Voltage kHz Frequency x 1000
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation. THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components
connected and fitted. “Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE: September 2000
Fig. 03.1
COMPONENTS
Component Connector / Type / Color Location / Access
BATTERY BT66 / BATTERY CABLE CLAMP TRUNK / BATTERY COVER
BT67 / BATTERY CABLE CLAMP
BODY PROCESSOR MODULE FC15 / 14-WAY AMP EEEC / GREY BULKHEAD / BEHIND GLOVE BOX
ENGINE CONTROL MODULE EM80 / 31-WAY AMP 403 / NATURAL ENGINE COMPARTMENT / CONTROL MODULE ENCLOSURE
EM81 / 24-WAY AMP 403 / NATURAL
EM82 / 17-WAY AMP 403 / NATURAL
EM83 / 28-WAY AMP 403 / NATURAL
EM84 / 22-WAY AMP 403 / NATURAL
EM85 / 12-WAY MULTILOCK 070 / WHITE
GENERATOR AN1 / EYELET ENGINE COMPARTMENT / RH FRONT
AN2 / EYELET
ST4 / EYELET
HIGH POWER PROTECTION MODULE BT60 / EYELET TRUNK / ADJACENT TO BATTERY
BT61 / EYELET
BT62 / EYELET
BT63 / EYELET
IGNITION SWITCH FC4 / 8-WAY MULTILOCK 070 / WHITE STEERING COLUMN
KEY TRANSPONDER MODULE FC22 / 20-WAY MULTILOCK 040 / GREEN BELOW INSTRUMENT PACK
NEUTRAL SWITCH CC21 / 3-WAY MULTILOCK 070 / GREY GEAR SELECTOR ASSEMBLY / CENTER CONSOLE
REGULATOR (GENERATOR) PI50 / 3-WAY SUMITOMO 92 / BLACK ENGINE COMPARTMENT / RH FRONT
STARTER MOTOR ST1 / EYELET ENGINE COMPARTMENT / ENGINE BLOCK / RH SIDE
ST2 / EYELET
ST3 / EYELET
SUPPRESSION MODULE AN3 / 3-WAY ECONOSEAL III LC / RED ENGINE COMPARTMENT / RIGHT FRONT
RELAYS
Relay Case Color Connector / Color Location / Access
STARTER RELAY BROWN EM50 / BROWN CONTROL MODULE ENCLOSURE RELAYS / ENGINE COMPARTMENT
HARNESS-TO-HARNESS CONNECTORS
Connector Type / Color Location / Access
EM2 20-WAY MULTILOCK 070 / GREY PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
EM3 18-WAY MULTILOCK 070 / WHITE PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
EM60 2-WAY ECONOSEAL J2 / GREY ENGINE COMPARTMENT / ADJACENT RH TO FALSE BULKHEAD
FC7 20-WAY MULTILOCK 070 / YELLOW ABOVE DIMMER MODULE / COIN TRAY
PI1 57-WAY SUMITOMO TS090 / BLACK ENGINE COMPARTMENT / BULKHEAD / REAR OF ENGINE
PI2 13-WAY ECONOSEAL III LC / BLACK ENGINE COMPARTMENT / BRACKET ON TOP OF TRANSMISSION
ST5 EYELET ENGINE COMPARTMENT / RH FALSE BULKHEAD
ST6 EYELET ENGINE COMPARTMENT / RH FALSE BULKHEAD
GROUNDS
Ground Location / Type
BT65 EYELET (SINGLE) – BATTERY GROUND STUD
CC3R EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
FC17L EYELET (PAIR) – EMS BULKHEAD GROUND STUD
FOR CONTROL MODULE PIN OUT INFORMATION, UNFOLD PAGE TO LEFT.
CONTROL MODULE PIN OUT INFORMATION
BODY PROCESSOR MODULE
Pin Description Active Inactive
I FC15-7 NEUTRAL SWITCH STATUS GROUND (N) B+ (P, R, D, 4, 3, 2)
D FC15-21 SERIAL COMMUNICATION – KEY TRANSPONDER ENCODED COMMUNICATIONS
D FC15-39 SECURITY ACKNOWLEDGE ENCODED COMMUNICATIONS
I FC15-41 STARTER ENGAGE REQUEST GROUND (CRANKING) B+
O FC15-73 STARTER RELAY ACTIVATE GROUND (CRANKING) B+
I FC15-80 BATTERY SUPPLY VOLTAGE B+ B+
D FC15-92 ENCODED COMMUNICATIONS
ENGINE CONTROL MODULE
Pin Description Active Inactive
I EM81-12 PARK / NEUTRAL CONFIRMATION B+ (P, N) GROUND (R,D,4,3,2)
I EM82-2 ENGINE CRANK GROUND (CRANKING)
D EM82-15 OK TO START ENCODED COMMUNICATIONS
D EM82-16 SECURITY ACKNOWLEDGE ENCODED COMMUNICATIONS
KEY TRANSPONDER MODULE
Pin Description Active Inactive
D FC22-9 SERIAL COMMUNICATION ENCODED COMMUNICATIONS
D FC22-11 SERIAL COMMUNICATION – BPM ENCODED COMMUNICATIONS
D FC22-16 OK TO START ENCODED COMMUNICATIONS
D FC22-17 SECURITY ACKNOWLEDGE ENCODED COMMUNICATIONS
User Instructions
CONTROL MODULE PIN OUT INFORMATION FIGURE NUMBER COMPONENT, RELAY, CONNECTOR AND
GROUND INFORMATION
DATE OF ISSUE
DATA PAGE
FIGURE MODEL RANGE AND YEAR TITLE FIGURE NUMBER
KEY TO REFERENCE SYMBOLS VARIANT, VIN RANGE AND DATE OF ISSUE
FIGURE PAGE