Filter
Top Products
The following abbreviations are used to represent values for Control Module Pin-Out data
I Input SG Sensor Ground S SCP Network V Voltage (DC)
O Output A ACP Network D Serial and Encoded Data Hz Frequency
SS Sensor Supply V C CAN (Network) B+ Battery Voltage kHz Frequency x 1000
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation. THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components
connected and fitted. “Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE: September 2000
Fig. 04.2
COMPONENTS
Component Connector / Type / Color Location / Access
AIR CONDITIONING COMPRESSOR CLUTCH PI36 / 1-WAY SUMITOMO 90 A TYPE / BLACK ENGINE COMPARTMENT / A/C COMPRESSOR
A/CCM: AIR CONDITIONING CONTROL MODULE CC28 / 26-WAY MULTILOCK 47 / GREY RH SIDE OF TRANSMISSION TUNNEL / GLOVE BOX ASSEMBLY
CC29 / 16-WAY MULTILOCK 47 / GREY
CC30 / 12-WAY MULTILOCK 47 / GREY
CC31 / 22-WAY MULTILOCK 47 / GREY
BRAKE CANCEL SWITCH CC40 / 4-WAY MULTILOCK 070 / WHITE ADJACENT TO THE BRAKE PEDAL MOUNTING ASSEMBLY
CRUISE CONTROL ON / OFF SWITCH CC20 / 10-WAY AMP MICRO QUAD LOCK / NATURAL CENTER CONSOLE ASSEMBLY
CRUISE CONTROL SWITCHES (STEERING WHEEL) SW3 / 3-WAY EPC / BLACK CENTER OF STEERING WHEEL
ENGINE CONTROL MODULE EM80 / 31-WAY AMP 403 / NATURAL ENGINE COMPARTMENT / CONTROL MODULE ENCLOSURE
EM81 / 24-WAY AMP 403 / NATURAL
EM82 / 17-WAY AMP 403 / NATURAL
EM83 / 28-WAY AMP 403 / NATURAL
EM84 / 22-WAY AMP 403 / NATURAL
EM85 / 12-WAY MULTILOCK 070 / WHITE
FUEL INJECTOR – 1A PI7 / 2-WAY AMP JUNIOR POWER TIMER / BLACK ENGINE COMPARTMENT / INTAKE MANIFOLD / FUEL RAIL
FUEL INJECTOR – 1B PI11 / 2-WAY AMP JUNIOR POWER TIMER / BLACK ENGINE COMPARTMENT / INTAKE MANIFOLD / FUEL RAIL
FUEL INJECTOR – 2A PI8 / 2-WAY AMP JUNIOR POWER TIMER / BLACK ENGINE COMPARTMENT / INTAKE MANIFOLD / FUEL RAIL
FUEL INJECTOR – 2B PI12 / 2-WAY AMP JUNIOR POWER TIMER / BLACK ENGINE COMPARTMENT / INTAKE MANIFOLD / FUEL RAIL
FUEL INJECTOR – 3A PI9 / 2-WAY AMP JUNIOR POWER TIMER / BLACK ENGINE COMPARTMENT / INTAKE MANIFOLD / FUEL RAIL
FUEL INJECTOR – 3B PI13 / 2-WAY AMP JUNIOR POWER TIMER / BLACK ENGINE COMPARTMENT / INTAKE MANIFOLD / FUEL RAIL
FUEL INJECTOR – 4A PI10 / 2-WAY AMP JUNIOR POWER TIMER / BLACK ENGINE COMPARTMENT / INTAKE MANIFOLD / FUEL RAIL
FUEL INJECTOR – 4B PI14 / 2-WAY AMP JUNIOR POWER TIMER / BLACK ENGINE COMPARTMENT / INTAKE MANIFOLD / FUEL RAIL
FUEL PUMP BT17 / 6-WAY SUMITOMO DL090 / NATURAL EVAPORATIVE FLANGE / TOP OF FUEL TANK
FUSE BOX – TRUNK BT10 / 10-WAY U.T.A. FUSE BOX / NATURAL TRUNK ELECTRICAL CARRIER
BT11 / 10-WAY U.T.A. FUSE BOX / BLACK
BT12 / 10-WAY U.T.A. FUSE BOX / GREEN
BT13 / 10-WAY U.T.A. FUSE BOX / BLUE
BT64 / EYELET
IGNITION COIL – 1A PI51 / 4-WAY YAZAKI / BLACK ENGINE COMPARTMENT / CAMSHAFT COVER
IGNITION COIL – 1B PI55 / 4-WAY YAZAKI / BLACK ENGINE COMPARTMENT / CAMSHAFT COVER
IGNITION COIL – 2A PI52 / 4-WAY YAZAKI / BLACK ENGINE COMPARTMENT / CAMSHAFT COVER
IGNITION COIL – 2B PI56 / 4-WAY YAZAKI / BLACK ENGINE COMPARTMENT / CAMSHAFT COVER
IGNITION COIL – 3A PI53 / 4-WAY YAZAKI / BLACK ENGINE COMPARTMENT / CAMSHAFT COVER
IGNITION COIL – 3B PI57 / 4-WAY YAZAKI / BLACK ENGINE COMPARTMENT / CAMSHAFT COVER
IGNITION COIL – 4A PI54 / 4-WAY YAZAKI / BLACK ENGINE COMPARTMENT / CAMSHAFT COVER
IGNITION COIL – 4B PI58 / 4-WAY YAZAKI / BLACK ENGINE COMPARTMENT / CAMSHAFT COVER
RADIATOR FAN CONTROL RELAY MODULE LF31 / 8-WAY TRW / BLACK ENGINE COMPARTMENT / ADJACENT TO LH CRUSH TUBE
RADIATOR FAN – LH CF1 / 2-WAY REINSHAGEN / BLACK ENGINE COMPARTMENT / BELOW LH FAN
RADIATOR FAN – RH CF2 / 2-WAY REINSHAGEN / BLACK ENGINE COMPARTMENT / BELOW RH FAN
REFRIGERANT 4-WAY PRESSURE SWITCH LF26 / 6-WAY ECONOSEAL III LC / BLACK ENGINE COMPARTMENT / ADJACENT TO LH SIDE OF RADIATOR
RELAYS
Relay Case Color Connector / Color Location / Access
AIR CONDITIONING COMPRESSOR CLUTCH RELAY BROWN EM52 / BROWN CONTROL MODULE ENCLOSURE RELAYS / ENGINE COMPARTMENT
FUEL INJECTION RELAY BLACK EM25 / BLACK CONTROL MODULE ENCLOSURE RELAYS / ENGINE COMPARTMENT
FUEL PUMP RELAY BROWN BUS RELAY #4, TRUNK FUSE BOX / TRUNK
IGNITION COIL RELAY BROWN EM26 / BROWN CONTROL MODULE ENCLOSURE RELAYS / ENGINE COMPARTMENT
HARNESS-TO-HARNESS CONNECTORS
Connector Type / Color Location / Access
BT4 54-WAY THROUGH PANEL / GREY BELOW PARCEL SHELF / TRUNK / REAR BULKHEAD / RH SIDE
EM1 12-WAY AUGAT 1.6 / BLACK ENGINE COMPARTMENT / ADJACENT TO ABS PUMP
EM3 18-WAY MULTILOCK 070 / WHITE PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
EM51 12-WAY AUGAT 1.6 / GREY ENGINE COMPARTMENT / ADJACENT TO ABS PUMP
EM53 20-WAY MULTILOCK 070 / WHITE PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
FC1 54-WAY THROUGH PANEL CONNECTOR / GREY BELOW PASSENGER SIDE AIR VENT / GLOVE BOX ASSEMBLY
LF32 4-WAY YAZAKI / GREY FORWARD OF LH FRONT SUSPENSION ARM
PI1 57-WAY SUMITOMO TS090 / BLACK ENGINE COMPARTMENT / BULKHEAD / REAR OF ENGINE
PI2 13-WAY ECONOSEAL III LC / BLACK ENGINE COMPARTMENT / BRACKET ON TOP OF TRANSMISSION
SC3 12-WAY MULTILOCK 070 / GREY ADJACENT TO STEERING COLUMN MOTOR
SW1 12-WAY MULTILOCK 040 / BLACK INSIDE STEERING COLUMN COWL
SW2 6-WAY JST / BLACK CENTER OF STEERING WHEEL
GROUNDS
Ground Location / Type
BT20 EYELET (SINGLE) – TRUNK / RH REAR GROUND STUD
EM8R EYELET (PAIR) – EMS LH GROUND STUD
EM16R EYELET (PAIR) – EMS BULKHEAD GROUND STUD
EM17 EYELET (SINGLE) – EMS BULKHEAD GROUND STUD
FC17R EYELET (PAIR) – EMS BULKHEAD GROUND STUD
LF10L EYELET (PAIR) – LH FORWARD GROUND STUD
LF10R EYELET (PAIR) – LH FORWARD GROUND STUD
LF20L EYELET (PAIR) – RH FORWARD GROUND STUD
FOR CONTROL MODULE PIN OUT INFORMATION, UNFOLD PAGE TO LEFT.
CONTROL MODULE PIN OUT INFORMATION
AIR CONDITIONING CONTROL MODULE
Pin Description Active Inactive
I CC28-1 COMPRESSOR CLUTCH STATUS B+ (ON) 0 V
O CC30-1 AIR CONDITIONING ELECTRICAL LOAD SIGNAL B+ 0 V
I CC31-7 LOAD INHIBIT 0 V B+
O CC31-9 COMPRESSOR CLUTCH ON REQUEST B+ 0 V
I CC31-17 REFRIGERANT 4-WAY PRESSURE SWITCH 0 V (2 – 30 BAR) B+ (OUT OF ACTIVE RANGE)
ENGINE CONTROL MODULE
Pin Description Active Inactive
I EM80-10 REFRIGERANT 4-WAY PRESSURE SWITCH HIGH PRESSURE GROUND @ 20 BAR (290 PSI)
I EM80-11 A/CCM COMPRESSOR CLUTCH REQUEST B+ GROUND
O EM80-12 ELECTRICAL LOAD INHIBIT GROUND B+
O EM80-16 CRUISE CONTROL ON STATUS LED GROUND B+
D EM80-17 SERIAL COMMUNICATIONS
D EM80-18 SERIAL COMMUNICATIONS
D EM80-19 ECM PROGRAMMING
I EM80-20 CRUISE CONTROL BRAKE CANCEL REQUEST GROUND B+
I EM80-22 REFRIGERANT 4-WAY PRESSURE SWITCH HIGH PRESSURE GROUND @ 12 BAR (174 PSI)
I EM80-23 A/CCM ELECTRICAL LOAD REQUEST (HEATED WINDSHIELD) B+ GROUND
O EM80-25 AIR CONDITIONING COMPRESSOR RELAY ACTIVATE GROUND B+
O EM81-04 PARALLEL (HIGH) SPEED FAN ACTIVATE GROUND B+
O EM81-05 SERIES (LOW) SPEED FAN ACTIVATE GROUND B+
I EM81-13 CRUISE CONTROL ON REQUEST B+ GROUND
I EM81-14 CRUISE CONTROL SET +/- 7.3 V = (+), 8.8 V = (–)B+
I EM81-15 CRUISE CONTROL CANCEL / RESUME 7.3 V = RESUME, 8.8 V = CANCEL B+
I EM83-04 FUEL PUMP RELAY ACTIVATE GROUND B+
I EM83-10 IGNITION MODULES 1A, 2B, 3B, 4A OBD MONITOR 23 Hz @ IDLE (5 V)
I EM83-11 IGNITION MODULES 1B, 2A, 3A, 4B OBD MONITOR 23 Hz @ IDLE (5 V)
O EM84-02 INJECTOR 1A ACTIVATE GROUND B+
O EM84-03 INJECTOR 3B ACTIVATE GROUND B+
O EM84-04 INJECTOR 2B ACTIVATE GROUND B+
O EM84-05 INJECTOR 4A ACTIVATE GROUND B+
O EM84-06 INJECTOR 1B ACTIVATE GROUND B+
O EM84-09 IGNITION MODULE 4A SWITCHING GROUND (85 – 90% DUTY CYCLE @ IDLE) B+
O EM84-10 IGNITION MODULE 3A SWITCHING GROUND (85 – 90% DUTY CYCLE @ IDLE) B+
O EM84-11 IGNITION MODULE 2A SWITCHING GROUND (85 – 90% DUTY CYCLE @ IDLE) B+
O EM84-12 IGNITION MODULE 1A SWITCHING GROUND (85 – 90% DUTY CYCLE @ IDLE) B+
I EM84-13 INJECTOR 4B ACTIVATE GROUND B+
I EM84-14 INJECTOR 3A ACTIVATE GROUND B+
O EM84-17 IGNITION MODULE 4B SWITCHING GROUND (85 – 90% DUTY CYCLE @ IDLE) B+
O EM84-18 IGNITION MODULE 3B SWITCHING GROUND (85 – 90% DUTY CYCLE @ IDLE) B+
O EM84-19 IGNITION MODULE 2B SWITCHING GROUND (85 – 90% DUTY CYCLE @ IDLE) B+
O EM84-20 IGNITION MODULE 1B SWITCHING GROUND (85 – 90% DUTY CYCLE @ IDLE) B+
O EM84-21 INJECTOR 2A ACTIVATE GROUND B+