Filter
Top Products
The following abbreviations are used to represent values for Control Module Pin-Out data
I Input SG Sensor Ground S SCP Network V Voltage (DC)
O Output A ACP Network D Serial and Encoded Data Hz Frequency
SS Sensor Supply V C CAN (Network) B+ Battery Voltage kHz Frequency x 1000
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation. THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components
connected and fitted. “Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE: September 2000
Fig. 09.1
COMPONENTS
Component Connector / Type / Color Location / Access
BODY PROCESSOR MODULE FC15 / 14-WAY AMP EEEC / GREY BULKHEAD / BEHIND GLOVE BOX
CENTER CONSOLE SWITCH PACK CC1 / 16-WAY FORD IDC S.U. / BLACK CENTER CONSOLE SWITCH PACK
DIRECTION INDICATOR LAMP – LH FRONT BL2 / 2-WAY REINSHAGEN / VOLKSWAGEN / BLACK FRONT BUMPER – LH SIDE
DIRECTION INDICATOR LAMP – RH FRONT BR2 / 2-WAY REINSHAGEN / VOLKSWAGEN / BLACK FRONT BUMPER – RH SIDE
FOG LAMP SWITCHES FC3 / 10-WAY AMP MICRO QUAD LOCK / NATURAL FASCIA / OUTBOARD OF STEERING COLUMN
FOG LAMP – LH FRONT BL4 / 2-WAY DELPHI / PACKARD METRIPACK 280 / GREY FRONT BUMPER – LH SIDE
FOG LAMP – RH FRONT BR4 / 2-WAY DELPHI / PACKARD METRIPACK 280 / GREY FRONT BUMPER – RH SIDE
LAMP UNIT – LH FRONT LF38 / 6-WAY AUGAT 1.6 / BLACK ENGINE COMPARTMENT / LH FRONT
LAMP UNIT – RH FRONT LF40 / 6-WAY AUGAT 1.6 / BLACK ENGINE COMPARTMENT / RH FRONT
FUSE BOX – ENGINE COMPARTMENT LF5 / 10-WAY U.T.A. FUSE BOX / NATURAL ENGINE COMPARTMENT / LH FRONT
LF6 / 10-WAY U.T.A. FUSE BOX / BLACK
LF7 / 10-WAY U.T.A. FUSE BOX / GREEN
LF8 / 10-WAY U.T.A. FUSE BOX / BLUE
ST19 / EYELET
INSTRUMENT PACK FC24 / 26-WAY AMP MICRO QUAD LOCK / BLACK FASCIA
FC25 / 26-WAY AMP MICRO QUAD LOCK / YELLOW
LIGHTING STALK (COLUMN SWITCHGEAR) SC2 / 10-WAY MULTILOCK 070 / YELLOW COLUMN SWITCHGEAR HARNESS /
ADJACENT TO STEERING COLUMN MOTOR
SIDE DI REPEATER – LH (ROW ONLY) LF17 / 2-WAY AMP JUNIOR POWER TIMER / BLACK BEHIND LEFT HAND WHEEL ARCH LINER
SIDE DI REPEATER – RH (ROW ONLY) CA80 / 2-WAY AMP JUNIOR POWER TIMER / BLACK BEHIND RIGHT HAND WHEEL ARCH LINER
SIDE MARKER – LH FRONT (NAS ONLY) BL5 / 2-WAY REINSHAGEN / VOLKSWAGEN / BLACK FRONT BUMPER – LH SIDE
SIDE MARKER – RH FRONT (NAS ONLY) BR5 / 2-WAY REINSHAGEN / VOLKSWAGEN / BLACK FRONT BUMPER – RH SIDE
RELAYS
Relay Case Color Connector / Color Location / Access
DIP BEAM RELAY BROWN BUS RELAY #5, ENGINE COMPARTMENT FUSE BOX / ENGINE COMPARTMENT
FRONT FOG RELAY BROWN BUS RELAY #2, ENGINE COMPARTMENT FUSE BOX / ENGINE COMPARTMENT
MAIN BEAM RELAY BROWN BUS RELAY #3, ENGINE COMPARTMENT FUSE BOX / ENGINE COMPARTMENT
HARNESS-TO-HARNESS CONNECTORS
Connector Type / Color Location / Access
BL1 4-WAY AUGAT 1.6 / BLACK BEHIND LEFT HAND WHEEL ARCH LINER
BR1 4-WAY AUGAT 1.6 / BLACK ADJACENT TO BOTTOM OF WASHER FLUID RESERVOIR
FC5 54-WAY THROUGH PANEL CONNECTOR / GREY BELOW DRIVER SIDE AIR VENT / COIN TRAY
FC7 20-WAY MULTILOCK 070 / YELLOW ABOVE DIMMER MODULE / COIN TRAY
LF3 54-WAY THROUGH PANEL CONNECTOR / GREY LH ‘A’ POST / LOWER ‘A’ POST FINISHER
GROUNDS
Ground Location / Type
CC3L EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
CC3R EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
FC17L EYELET (PAIR) – EMS BULKHEAD GROUND STUD
FC17R EYELET (PAIR) – EMS BULKHEAD GROUND STUD
LF18L EYELET (PAIR) – LH FORWARD GROUND STUD
LF19R EYELET (PAIR) – RH FORWARD GROUND STUD
FOR CONTROL MODULE PIN OUT INFORMATION, UNFOLD PAGE TO LEFT.
CONTROL MODULE PIN OUT INFORMATION
BODY PROCESSOR MODULE
Pin Description Active Inactive
O FC15-1 RH FRONT SIDE LAMP SUPPLY B+ GROUND
O FC15-2 LH FRONT DI LAMP SUPPLY B+ (PULSED) GROUND
O FC15-3 RH FRONT DI LAMP SUPPLY B+ (PULSED) GROUND
I FC15-14 HEADLAMP MAIN BEAM REQUEST GROUND B+
I FC15-15 IGNITION SWITCHED GROUND GROUND B+
I FC15-16 SIDE LAMP REQUEST GROUND B+
O FC15-20 FRONT FOG LAMP RELAY ACTIVATE GROUND B+
O FC15-27 LH SIDE DI REPEATER LAMP SUPPLY (ROW ONLY) B+ (PULSED) GROUND
I FC15-30 HEADLAMP FLASH REQUEST GROUND (MOMENTARY) B+
I FC15-38 FRONT FOG LAMP REQUEST GROUND B+
I FC15-41 STARTER ENGAGE REQUEST GROUND (CRANKING) B+
I FC15-42 HEADLAMP DIP REQUEST GROUND (MOMENTARY) B+
O FC15-45 MAIN BEAM RELAY ACTIVATE GROUND B+
O FC15-53 LH FRONT SIDE LAMP SUPPLY B+ GROUND
I FC15-59 HAZARD LAMP REQUEST GROUND (MOMENTARY) B+
I FC15-61 RH DI REQUEST GROUND B+
O FC15-68 DIP BEAM RELAY ACTIVATE GROUND B+
I FC15-79 BATTERY SUPPLY VOLTAGE B+ B+
I FC15-80 BATTERY SUPPLY VOLTAGE B+ B+
O FC15-81 RH SIDE DI REPEATER LAMP SUPPLY (ROW ONLY) B+ (PULSED) GROUND
S FC15-84 SCP NETWORK 2 – 1600 Hz
S FC15-85 SCP NETWORK 2 – 1600 Hz
I FC15-88 LH DI REQUEST GROUND B+
O FC15-96 HAZARD LAMP STATUS GROUND (PULSE) B+
INSTRUMENT PACK
Pin Description Active Inactive
S FC24-13 SCP NETWORK 2 – 1600 Hz
S FC24-14 SCP NETWORK 2 – 1600 Hz
NOTE: Refer to the Appendix at the rear of this book for CAN and SCP Network messages.