Filter
Top Products
The following abbreviations are used to represent values for Control Module Pin-Out data
I Input SG Sensor Ground S SCP Network V Voltage (DC)
O Output A ACP Network D Serial and Encoded Data Hz Frequency
SS Sensor Supply V C CAN (Network) B+ Battery Voltage kHz Frequency x 1000
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation. THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components
connected and fitted. “Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE: September 2000
Fig. 18.1
COMPONENTS
Component Connector / Type / Color Location / Access
AIRBAG / SRS SINGLE POINT SENSOR CA61 / 50-WAY ELO50 / YELLOW BELOW CENTER CONSOLE ASSEMBLY
AIRBAG – DRIVER SIDE SW11 / 3-WAY EPC / BLACK CENTER OF STEERING WHEEL
AIRBAG – PASSENGER SIDE CA81 / 3-WAY CARDEL / FORD / GREY PASSENGER AIR BAG
IMPACT SENSOR – LH CA15 / 3-WAY MOLEX C-GRID / BLACK INSIDE ‘B/C’ POST / ‘B/C’ POST TRIM
IMPACT SENSOR – RH CA22 / 3-WAY MOLEX C-GRID / BLACK INSIDE ‘B/C’ POST / ‘B/C’ POST TRIM
SEAT BELT PRETENSIONER – LH CA62 / 2-WAY FORD AIRBAG / YELLOW INSIDE LH ‘B/C’ POST / ‘B/C’ POST TRIM
SEAT BELT PRETENSIONER – RH CA65 / 2-WAY FORD AIRBAG / YELLOW INSIDE RH ‘B/C’ POST / ‘B/C’ POST TRIM
SIDE AIRBAG – DRIVER SD15 / 2-WAY FORD AIRBAG / YELLOW DRIVER SEAT / SIDE
SIDE AIRBAG – PASSENGER SP15 / 2-WAY FORD AIRBAG / YELLOW PASSENGER SEAT / SIDE
HARNESS-TO-HARNESS CONNECTORS
Connector Type / Color Location / Access
CA66 3-WAY EPC AIRBAG / BLACK BELOW SEAT
CA72 3-WAY EPC AIRBAG / CARD / BLACK BELOW SEAT
FC5 54-WAY THROUGH PANEL CONNECTOR / GREY BELOW DRIVER SIDE AIR VENT / COIN TRAY
SW10 3-WAY FORD AIRBAG / BLACK CENTER OF STEERING WHEEL
GROUNDS
Ground Location / Type
CA48 EYELET (SINGLE) – RH HEELBOARD POST GROUND SCREW (AIRBAG ONLY GROUND)
FOR CONTROL MODULE PIN OUT INFORMATION, UNFOLD PAGE TO LEFT.
CONTROL MODULE PIN OUT INFORMATION
AIRBAG / SRS SINGLE POINT SENSOR
Pin Description Active Inactive
O CA61-1 LH SEAT BELT PRETENSIONER POWER SUPPLY B+ OPEN CIRCUIT
O CA61-2 LH SEAT BELT PRETENSIONER GROUND SUPPLY GROUND OPEN CIRCUIT
O CA61-3 RH SEAT BELT PRETENSIONER POWER SUPPLY B+ OPEN CIRCUIT
O CA61-4 RH SEAT BELT PRETENSIONER GROUND SUPPLY GROUND OPEN CIRCUIT
I CA61-5 IGNITION SUPPLY VOLTAGE B+ GROUND
I CA61-6 GROUND SUPPLY GROUND GROUND
O CA61-7 INSTRUMENT PACK ‘SRS’ MIL GROUND (NO FAULT) B+
D CA61-9 DIAGNOSTIC OUTPUT SERIAL OUTPUT ENCODED COMMUNICATIONS
O CA61-10 STEERING WHEEL AIRBAG POWER SUPPLY B+ OPEN CIRCUIT
O CA61-11 STEERING WHEEL AIRBAG GROUND SUPPLY GROUND OPEN CIRCUIT
O CA61-13 PASSENGER FASCIA AIRBAG POWER SUPPLY B+ OPEN CIRCUIT
O CA61-14 PASSENGER FASCIA AIRBAG GROUND SUPPLY GROUND OPEN CIRCUIT
O CA61-16 DRIVER SIDE AIRBAG POWER SUPPLY B+ OPEN CIRCUIT
O CA61-17 DRIVER SIDE AIRBAG GROUND SUPPLY GROUND OPEN CIRCUIT
O CA61-18 PASSENGER SIDE AIRBAG POWER SUPPLY B+ OPEN CIRCUIT
O CA61-19 PASSENGER SIDE AIRBAG GROUND SUPPLY GROUND OPEN CIRCUIT
I CA61-20 LH SIDE IMPACT SENSOR GROUND SUPPLY GROUND B+
I CA61-21 RH SIDE IMPACT SENSOR GROUND SUPPLY GROUND B+
I CA61-22 LH SIDE IMPACT SENSOR STATUS GROUND (SHORTED) B+
I CA61-23 RH SIDE IMPACT SENSOR STATUS GROUND (SHORTED) B+
I CA61-24 LH SIDE IMPACT SENSOR GROUND SUPPLY STATUS GROUND (NO FAULT) GROUND
I CA61-25 RH SIDE IMPACT SENSOR GROUND SUPPLY STATUS GROUND (NO FAULT) GROUND
O CA61-40 SRS AUDIBLE BACKUP ENCODED COMMUNICATIONS