Filter
Top Products
The following abbreviations are used to represent values for Control Module Pin-Out data
I Input SG Sensor Ground S SCP Network V Voltage (DC)
O Output A ACP Network D Serial and Encoded Data Hz Frequency
SS Sensor Supply V C CAN (Network) B+ Battery Voltage kHz Frequency x 1000
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation. THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components
connected and fitted. “Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE: September 2000
Fig. 12.2
COMPONENTS
Component Connector / Type / Color Location / Access
BODY PROCESSOR MODULE FC15 / 14-WAY AMP EEEC / GREY BULKHEAD / BEHIND GLOVE BOX
DOOR CONTROL MODULE – DRIVER DD10 / 22-WAY FORD 2.8 TIMER / BLUE DOOR CASING / TRIM PANEL
DD11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR CONTROL MODULE – DRIVER REAR RD10 / 22-WAY FORD 2.8 TIMER / BLUE DOOR CASING / TRIM PANEL
RD11 / 22-WAY FORD 2.8 TIMER / BLACK
SEAT CONTROL MODULE – DRIVER SD1 / 16-WAY FORD 2.8 TIMER / BLACK DRIVER SEAT / UNDER
SD2 / 26-WAY FORD IDC / BLACK
SD3 / 10-WAY FORD 2.8 TIMER / BLACK
SEAT CUSHION HEATERS – DRIVER SD7 / 3-WAY MULTILOCK 070 / YELLOW DRIVER SEAT
SEAT HEATER SWITCH CC1 / 16-WAY FORD IDC S.U. / BLACK CENTER CONSOLE SWITCH PACK
(CENTER CONSOLE SWITCH PACK)
SEAT LUMBAR PUMP – DRIVER SD10 / 3-WAY MULTILOCK 070 / YELLOW DRIVER SEAT
SEAT MOTORS – DRIVER SD4 / 6-WAY MULTILOCK 070 / GREY DRIVER SEAT / UNDER
SD6 / 6-WAY MULTILOCK 070 / YELLOW
SD11 / 6-WAY MULTILOCK 070 / WHITE
SD12 / 6-WAY MULTILOCK 070 / WHITE
SD13 / 6-WAY MULTILOCK 070 / YELLOW
SEAT SQUAB HEATERS – DRIVER SD9 / 3-WAY MULTILOCK 070 / GREY DRIVER SEAT
SWITCH PACK – DRIVER SEAT SD5 / 16-WAY MULTILOCK 040 / BLACK DRIVER SEAT
RELAYS
Relay Case Color Connector / Color Location / Access
SEAT HEATER RELAY – DRIVER BROWN SD14 / BROWN FRONT SEAT RELAYS / UNDER SEAT
HARNESS-TO-HARNESS CONNECTORS
Connector Type / Color Location / Access
CA8 20-WAY MULTILOCK 070 / WHITE DRIVER ‘A’ POST / DOOR HARNESS GAITER
CA13 4-WAY MULTILOCK 070 / WHITE DRIVER ‘B/C’ POST / DOOR HARNESS GAITER
CA23 10-WAY MULTILOCK 070 / WHITE BELOW DRIVER SEAT
FC1 54-WAY THROUGH PANEL CONNECTOR / GREY BELOW PASSENGER SIDE AIR VENT / GLOVE BOX ASSEMBLY
FC5 54-WAY THROUGH PANEL CONNECTOR / GREY BELOW DRIVER SIDE AIR VENT / COIN TRAY
FC7 20-WAY MULTILOCK 070 / YELLOW ABOVE DIMMER MODULE / COIN TRAY
GROUNDS
Ground Location / Type
CA25L EYELET (PAIR) – PASSENGER SEAT GROUND STUD
CA25R EYELET (PAIR) – PASSENGER SEAT GROUND STUD
CA26L EYELET (PAIR) – DRIVER SEAT GROUND STUD
CA26R EYELET (PAIR) – DRIVER SEAT GROUND STUD
CC3L EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
FOR CONTROL MODULE PIN OUT INFORMATION, UNFOLD PAGE TO LEFT.
CONTROL MODULE PIN OUT INFORMATION
BODY PROCESSOR MODULE
Pin Description Active Inactive
I FC15-15 IGNITION SWITCHED GROUND GROUND B+
O FC15-17 SEAT HEATER STATUS (LHD = PASSENGER, RHD = DRIVER) GROUND B+
I FC15-32 IGNITION SWITCHED GROUND GROUND B+
I FC15-35 SEAT HEATER REQUEST (LHD = PASSENGER, RHD = DRIVER) GROUND (MOMENTARY) B+
I FC15-41 STARTER ENGAGE REQUEST GROUND (CRANKING) B+
O FC15-69 SEAT HEATER STATUS (LHD = DRIVER, RHD = PASSENGER) GROUND B+
I FC15-80 BATTERY SUPPLY VOLTAGE B+ B+
S FC15-84 SCP NETWORK 2 – 1600 Hz
S FC15-85 SCP NETWORK 2 – 1600 Hz
I FC15-86 SEAT HEATER REQUEST (LHD = DRIVER, RHD = PASSENGER) GROUND (MOMENTARY) B+
DRIVER SEAT CONTROL MODULE
Pin Description Active Inactive
O SD1-1 DRIVER SEAT SQUAB FORE / AFT RECLINE MOTOR SUPPLY B+ GROUND
O SD1-2 DRIVER SEAT SQUAB FORE / AFT RECLINE MOTOR SUPPLY B+ GROUND
O SD1-3 DRIVER SEAT CUSHION RAISE / LOWER FRONT MOTOR SUPPLY B+ GROUND
O SD1-4 DRIVER SEAT CUSHION RAISE / LOWER FRONT MOTOR SUPPLY B+ GROUND
O SD1-5 DRIVER HEADREST RAISE / LOWER MOTOR SUPPLY B+ GROUND
O SD1-6 DRIVER HEADREST RAISE / LOWER MOTOR SUPPLY B+ GROUND
O SD1-7 DRIVER SEAT CUSHION FORE / AFT MOTOR SUPPLY B+ GROUND
O SD1-8 DRIVER SEAT CUSHION FORE / AFT MOTOR SUPPLY B+ GROUND
I SD1-9 DRIVER SEAT CUSHION FORE MOVEMENT REQUEST B+ GROUND
I SD1-10 DRIVER SEAT CUSHION AFT MOVEMENT REQUEST B+ GROUND
I SD1-11 DRIVER SEAT CUSHION LOWER REAR MOVEMENT REQUEST B+ GROUND
I SD1-12 DRIVER SEAT CUSHION RAISE REAR MOVEMENT REQUEST B+ GROUND
I SD1-13 DRIVER SEAT CUSHION RAISE FRONT MOVEMENT REQUEST B+ GROUND
I SD1-14 DRIVER SEAT CUSHION LOWER FRONT MOVEMENT REQUEST B+ GROUND
I SD1-15 DRIVER SEAT SQUAB AFT RECLINE MOVEMENT REQUEST B+ GROUND
I SD1-16 DRIVER SEAT SQUAB FORE RECLINE MOVEMENT REQUEST B+ GROUND
I SD3-1 MODULE IDENTIFICATION GROUND (DRIVER)
I SD3-2 POWER GROUND GROUND GROUND
O SD3-3 DRIVER SEAT RAISE / LOWER MOTOR SUPPLY B+ GROUND
O SD3-4 DRIVER SEAT RAISE / LOWER MOTOR SUPPLY B+ GROUND
I SD3-5 BATTERY POWER SUPPLY B+ B+
I SD3-6 DRIVER SEAT HEADREST RAISE MOVEMENT REQUEST B+ GROUND
I SD3-8 DRIVER SEAT HEADREST LOWER MOVEMENT REQUEST B+ GROUND
S SD3-9 SCP NETWORK 2 – 1600 Hz
S SD3-10 SCP NETWORK 2 – 1600 Hz
NOTE: Refer to the Appendix at the rear of this book for CAN and SCP Network messages.