Filter
Top Products
The following abbreviations are used to represent values for Control Module Pin-Out data
I Input SG Sensor Ground S SCP Network V Voltage (DC)
O Output A ACP Network D Serial and Encoded Data Hz Frequency
SS Sensor Supply V C CAN (Network) B+ Battery Voltage kHz Frequency x 1000
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation. THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components
connected and fitted. “Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE: September 2000
Fig. 05.2
COMPONENTS
Component Connector / Type / Color Location / Access
DUAL LINEAR SWITCH CC8 / 12-WAY MULTILOCK 070 / GREY RIGHT HAND SIDE OF GEAR SELECTOR / CENTER CONSOLE
GEAR SELECTOR ILLUMINATION MODULE CC14 / 10-WAY MULTILOCK 070 / WHITE CENTER CONSOLE ASSEMBLY
KICKDOWN SWITCH CC35 / 1-WAY LUCAR RIGHT ANGLE / CLEAR BELOW ACCELERATOR PEDAL
CC36 / 1-WAY LUCAR RIGHT ANGLE / CLEAR
MODE SWITCH (TRANSMISSION) CC4 / 10-WAY AMP MICRO QUAD LOCK / BLACK CENTER CONSOLE ASSEMBLY
TRANSMISSION CONTROL MODULE: AJ27 SC EM61 / 18-WAY AMP JUNIOR POWER TIMER / BLACK ENGINE COMPARTMENT / CONTROL MODULE ENCLOSURE
EM62 / 14-WAY AMP JUNIOR POWER TIMER / BLACK
TRANSMISSION ELECTRICAL CONNECTOR: AJ27 SC GB1 / 13-WAY KOSTAL 1.5 / BLACK TRANSMISSION
HARNESS-TO-HARNESS CONNECTORS
Connector Type / Color Location / Access
EM44 12-WAY AUGAT 1.6 / BLACK ENGINE COMPARTMENT / BRACKET ON TOP OF TRANSMISSION
EM53 20-WAY MULTILOCK 070 / WHITE PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
EM63 14-WAY MULTILOCK 070 / YELLOW PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
GROUNDS
Ground Location / Type
CC2R EYELET (PAIR) – DRIVE SHAFT TUNNEL GROUND STUD – LH SIDE
CC3L EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
CC3R EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
EM8R EYELET (PAIR) – EMS LH GROUND STUD
FOR CONTROL MODULE PIN OUT INFORMATION, UNFOLD PAGE TO LEFT.
CONTROL MODULE PIN OUT INFORMATION
GEAR SELECTOR ILLUMINATION MODULE
Pin Description Active Inactive
I CC14-1 IGNITION SWITCHED POWER SUPPLY B+ GROUND
C CC14-3 CAN NETWORK 15 – 1500 Hz @ 2.5 V
C CC14-4 CAN NETWORK 15 – 1500 Hz @ 2.5 V
I CC14-6 GROUND GROUND GROUND
C CC14-8 CAN NETWORK 15 – 1500 Hz @ 2.5 V
C CC14-9 CAN NETWORK 15 – 1500 Hz @ 2.5 V
TRANSMISSION CONTROL MODULE: AJ27 SC
Pin Description Active Inactive
I EM61-2 KICKDOWN SWITCH GROUND (= WOT) B+ (< WOT)
I EM61-3 SPORT MODE SWITCH 0 V = SPORT; 0 V = NORMAL
I EM61-25 DUAL LINEAR SWITCH VOLTAGE ENCODED GEAR RECOGNITION GROUND = R, D, 4, 3 B+ = P, N, 2
I EM61-26 DUAL LINEAR SWITCH VOLTAGE ENCODED GEAR RECOGNITION GROUND = N, D, 4, 2 B+ = P, R, 3
I EM61-27 DUAL LINEAR SWITCH VOLTAGE ENCODED GEAR RECOGNITION GROUND = N, 4, 3, 2 8 V = R, D B+ = P
I EM61-28 DUAL LINEAR SWITCH VOLTAGE ENCODED GEAR RECOGNITION GROUND = P, D, 3, 2 B+ = R, N, 4
I EM61-29 IGNITION SUPPLIED VOLTAGE B+ GROUND
I EM61-30 TCM / DUAL LINEAR SWITCH COMMON GROUND SUPPLY GROUND GROUND
C EM62-L CAN NETWORK 5 – 1500 Hz
C EM62-H CAN NETWORK 5 – 1500 Hz
I EM62-12 n2 SPEED SENSOR FEEDBACK 6V = 900 Hz @ 10 MPH (16 KPH); 1800 HZ @ 20 MPH (32 KH) (‘2’ SELECTED – ‘1’ ENGAGED)
O EM62-13 SPEED SENSOR COMMON VOLTAGE SUPPLY 5V
O EM62-14 ‘1-2 / 4-5’ SOLENOID ACTIVATE GROUND B+
O EM62-15 ‘3-4’ SOLENOID ACTIVATE GROUND B+
O EM62-16 ‘2-3’ SOLENOID ACTIVATE GROUND B+
O EM62-17 TCC SOLENOID ACTIVATE GROUND = LOCKED B+ = UNLOCKED
O EM62-33 SPEED SENSOR / FLUID TEMP. SENSOR COMMON GROUND GROUND GROUND
I EM62-34 FLUID TEMP. SENSOR FEEDBACK 1.75 V @ 90° C = R, D, 4, 3, 2 5 V = P, N
I EM62-35 n3 SPEED SENSOR FEEDBACK 6 V = 85 Hz @ 10 MPH (16 KPH); 170 Hz @ 20 MPH (32 KPH) (‘2’ SELECTED – ‘2’ ENGAGED)
O EM62-36 MODULATION PRESSURE REGULATOR ACTIVATE GROUND ( 42% PWM @ IDLE) B+
O EM62-37 SHIFT PRESSURE REGULATOR ACTIVATE GROUND ( 39% PWM @ IDLE) B+
O EM62-38 SOLENOID VALVE / PRESSURE REGULATOR COMMON VOLTAGE SUPPLY B+ GROUND
NOTE: Refer to the Appendix at the rear of this book for CAN and SCP Network messages.