KTM 450 SMR Motorcycle User Manual


 
STORAGE 69
6725$*(

Storage
Warning
Danger of poisoningFuel is poisonous and a health hazard.
Avoid contact between fuel and skin, eyes and clothing. Do not inhale fuel vapors. If fuel gets into your eyes, rinse imme-
diately with water and contact a doctor. Wash affected skin areas immediately with soap and water. If fuel is swallowed,
contact a doctor immediately. Change clothing that has come into contact with fuel. Store fuel in a suitable canister ac-
cording to regulations and keep it out of the reach of children.
Info
If you want to garage the motorcycle for a longer period, take the following actions.
Before storing the motorcycle, check all parts for function and wear. If service, repairs or replacements are necessary, you
should do this during the storage period (less workshop overload). In this way, you can avoid long workshop waiting times at the
start of the new season.
Clean the motorcycle. ( P. 68)
Change the engine oil and oil filter, and clean the oil screen. ( P. 63)
Check the antifreeze and coolant level. ( P. 55)
Drain the fuel from the tanks into a suitable container.
Empty the carburetor float chamber. ( P. 62)
Checking the tire air pressure. ( P. 49)
Remove the battery. ( P. 50)
Recharge the battery. ( P. 51)
Specification
Storage temperature of battery without direct sunshine. 0… 35°C (32… 95°F)
The storage place should be dry and not subject to large temperature differences.
Info
KTM recommends jacking up the motorcycle.
Jack up the motorcycle. ( P. 21)
Cover the motorcycle with a porous sheet or blanket. Do not use non-porous materials since they prevent humidity from escaping,
thus causing corrosion.
Info
Avoid running the engine for a short time only. Since the engine cannot warm up properly, the water vapor produced during
combustion condenses and causes valves and exhaust system to rust.
Putting into operation after storage
Remove the motorcycle from the work stand. ( P. 21)
Install the battery. ( P. 50)
Fill up with fuel. ( P. 17)
Checks before putting into operation ( P. 15)
Make a test ride.