Filter
Top Products
TABI.E OF CONTENTS
WARRANTY ....................... inside Front Cover
RULES FOR SAFE OPERATION
inside Front Cover
SPECIFICATIONS ............................... 1
NOMENCLATURE ........................................... 2
WIRING DIAGRAM ............................................... 3
INSTALLATION OF STAND-BY
POWER SYSTEMS ............................... 4
REPAIR PARTS ........................................ 25-28
Section 1 -- Preparation For Use
Alternator Unpacking and Removal
From Shipping Skid .............................. 5
Parts Shipped With Alternator ......................... 5
Wheel Kit Installation ..................................... 7
Lubrication ........................................... 8
Battery Installation ................................ 9
Battery Connections .................................. 9
Fill Fuel Tank ..................................... 10
Install Fuel Tank ................................ 10
Cord Sets for 120 Volt, 15 Amp Outlets ......... 10
Optional Wiring Connections - 240 Volt
Connector Plug .......................... 11
Optional Wiring Connections - 120 Volt,
30 Amp Connector Plug ....................... 11
Grounding The Alternator .......................... 12
Section 2 -- Operating Instructions
Do and Don't Chart ...................................... 13
Before Starting the Engine ................................ 14
Starting the Engine .................................. 15
Stopping the Engine ................................ 16
Wattage and Power .................................... 16
Using the 120 Volt, 15 Amp Outlets ................. 16
Using the 120 Volt, 30 Amp Outlet ............... 16
Using the 240 Volt, 20 Amp Outlet ................. 17
Don't Overload the Alternator ....................... 17
Motor Starting Requirements ........................ 17
Charging a Battery ......................................... 18
Section 3 -- Preventive Maintenance
Maintenance Chart ....................................... 19
General Inspection ................................... 19
Change Oil ............................................. 20
Service Air Cleaner ............................... 21
Inspect 30 Amp Fuse ............................... 21
Spark Plugs ......................................... 22
Clean Fuel Tank ....................................... 22
Inspect Cooling Fins ........................... 22
De-Carbonize Muffler .................................. 23
Replace Fuel Filter .................................. 23
De-Carbonize Engine Cylinder Heads ............ 23
Storage ............................................... 23
==
z
c3
Z
w
SPECIFICATIONS
Model Noo 58&326010
IWattage Capacity 4500 Watts Continuous (5600 watts m'omentary surgei .............
Voltage Output 120f240 Volts
Amperes (Maximum) ....................................37.,5 at 120 Voi"ts _18175at 240"Volts .......
Frequency ...... i ......................60 Hertz a{ 1800 rpm ...................
.....Phase(s) Single Phase
Driven Speed
Voltage Regulation
Electrical Outlets
Make and Model
Horsepower
No. of Cylinders
....Displacemen{ ........
Governed Speed
Fuel Tank Capacity
1800 rpm
Solid state "Voltage over Frequency" regulator maintains
2120 volts (_+ 2%) at 60 Hz.
...................... (2io' 120 Volt, 15 Amp
(1) - 120 Volt, 30 Amp
(1) - 240 Volt, 20 Amp
..... ,,, "",::',','L,,,, ......... ,,,
Briggs & Stratton Model No. 401415
Approximatei'y iO HIP. at 1800 rpm
2
Recommended Fuel
Crankcase Oil
Capacity
Spark Plug use' Champion J-8, Auto-Lite A-71i"or AC G046 ......
Set gap to .030 inch
Starting Electric Ring Gear
Cooling System .................... Forced airiCentrifugal' Blower Type) ............................
...... Air Cleaner ......................... ...............Dry paper cartridge w"it'lqoil f0ampre-cieaner '
1
40 Cubic Inches (656 cc's)
1800 rpm
5 Gallons (1&925 Liters)
........Use clean, fresh NON:LEADED gasot'ine (Leaded, REGULAR grade
gasoline is an acceptable substitute)
31/2 Pints (I.65 Liters)