Filter
Top Products
Trekker - Squab
MAINTENANCE
PLAN CPLAN A
PLAN B
500 km or 3 mois
5000 km or 2500 km* 10000 km or 5000 km*
* reforced maintenance
3
Depending on how the scooter is used, it is recommended to apply either - The normal maintenance plan or
- The reinforced maintenance plan.
The normal maintenance plan includes:
- Visit at 500 km or 3 months Plan A
- Periodic maintenance every 5000 km Plan B
- Periodic maintenance every 10000 km Plan C
The reinforced maintenance plan includes:
- Visit at 500 km Plan A
- Periodic maintenance every 2500 km Plan B
- Periodic maintenance every 5000 km Plan C
The reinforced maintenance is intended for vehicles used in so-called “severe” conditions: door to door sales, intensive urban
use (courrier), short journeys engine cold, areas with dusty atmospheres, frequent use of vehicles at an ambient temperature
above 30°C.
CHECK :
Idle speed adjustment XXX
Throttle XXX
Oil pump control XXX
Functioning of the electric equipment XXX
Front and rear brake control XXX
Fuel pipes XXX
Oil pipes XXX
Front brake fluid pipes XXX
State and pressure of tyres X
State, pressure and wear of tyres XX
Brake fluid level XXX
Level of battery electrolyte XXX
Tightening of nuts and bolts XXX
REPLACE :
Relay unit oil XX
Spark plug XX
Filter element of the intake silencer XX
Front brake pads (if necessary) X
Rear brake linings (if necessary) XX
Drive pulley rollers (if necessary) XX
Transmission belt X
CHECK AND UNCLOG
Piston X
Cylinder head X
Exhaust port X
CHECK AND LUBRICATE
Driven pulley :
movable driven face and needle bearing X
Drive pulley :
movable drive face and rollers X
Kick : driven gear and link ring X
CLEAN AND ADJUST
Carburettor X
VEHICLE TEST
Road test XXX
MAINTENANCE PLAN