Volkswagen W6202 Motorized Toy Car User Manual


  Open as PDF
of 20
 
W6202pr-0920
19
PROBLEM POSSIBLE CAUSE SOLUTION
Vehiclerunssluggishly Underchargedbattery Chargethebattery.Anewbatteryshouldhavebeen
chargedforatleast18hoursbeforeusingthevehiclefor
thersttime.Afterrst-timeuse,rechargethebatteryfor
atleast14hoursaftereachuse.Neverchargethebattery
longerthan30hours.
Checkallconnectors.Makesurethebatteryconnectoris
tightlypluggedintothechargerconnector,andthatthe
chargerispluggedintothewall.
Makesurepowerowtothewalloutletis“ON”.
Batteryneedscharging Besuretochargethebatteryaftereachuse.
Batteryisoldandwillnot
acceptfullcharge
Evenwithpropercare,arechargeablebatterydoesnot
lastforever.Averagebatterylifeis1to3yearsdepending
onvehicleuseanduseconditions.Replaceonlywith
aPowerWheels
®
6Volt(4.0amp/hr.)batterywithbuilt-in
thermalfuse.Donotsubstituteparts.
Vehicleisoverloaded Makesureyoudonotoverloadthevehiclebyallowing
morethanonerideratonetime,exceedingthe50lb.
maximumweightcapacity,orbytowingobjectsbehind
thevehicle.Ifthevehicleisoverloaded,thebuilt-in
thermalfuseinthebatterymay"trip."Onceafusehas
"tripped,"removeyourfootfromthepedalandwait
approximately25secondsbeforeoperatingthevehicle
again.Adjustthedrivingconditionstopreventrepeated
automaticshutdowns.
Drivingconditionsaretoostressful Useonlyongenerallylevelground.
Sometimesthevehicle
doesn’trun,butother
timesitdoes
Loosewireorconnector Checkallwiresaroundthemotorsandallconnectorsto
makesuretheyaretight.
Motororelectricalswitchdamage ContactyourlocalPowerWheels
®
authorizedservice
centerfordiagnosisandrepair.
Whenthefootpedal
ispressed,thevehicle
won’trunwithout
apush
Loosewireorconnector Checkallwiresaroundthemotorsandallconnectorsto
makesuretheyaretight.
“DeadSpot”onmotor ContactyourlocalPowerWheels
®
authorizedservice
centerfordiagnosisandrepair.
Battery’sthermalfuse
constantly"trips",
butthevehicleisnot
overloadednorthe
drivingconditions
toosevere
Damagedbattery ContactyourlocalPowerWheels
®
authorizedservice
centerfordiagnosisandrepair.
Childisswitchingbetween
FORWARDandREVERSE
withoutstopping
Teachyourchildtostopthevehiclebefore
switchingdirection.
Loudclackingor
grindingnoisefrom
amotor-gearbox
Brokengears ContactyourlocalPowerWheels
®
authorizedservice
centerfordiagnosisandrepair.
Chargergetswarm
duringuse
Itisnormalforsomechargerstoget
warmduringuseandisnotreasonfor
concern.Somechargersdonotget
warmduringuse.
Noactionrequired.
Ifyourchargerdoesnotgetwarmduringuse,itdoesnot
meanthatitisnotworkingproperly.
Batterymakes
asizzlingorgurgling
noisewhencharging
Itisnormalforsomebatteriesto
makenoiseandswellslightly
whilechargingandisnotreason
forconcern.
Noactionrequired.
Ifyourbatterydoesnotmakenoiseorswellslightly
duringcharging,itdoesnotmeanthatitisnotaccepting
thecharge.
PROBLEMS AND SOLUTIONS GUIDE
 previous