Filter
Top Products
5
3.0L GAS ENGINE SERVICE RECOMMENDATIONS
Maintenance Tasks Level 1 Level 2 Level 3 Level 4
Recommended to
be done monthly/
10 hrs.
Task
Comp.
(Date-
Initials)
Required to be
done 3 months/
Break-in /30 hrs.
Task
Comp.
(Date-
Initials)
Required to
be done Semi-
Annually/50 hrs.
Task
Comp.
(Date-
Initials)
Required to be done
Annually/ 100 hrs.
Task
Comp.
(Date-
Initials)
14. Visually inspect the unit look-
ing for leaks, wear or damage,
loose connections or compo-
nents, and corrosion. Correct
as necessary.
• • • •
15. Test the engine and transfer
switch safety devices. Correct
and/or adjust as necessary.
•
16. Initiate an automatic start and
transfer of the unit to site load
and exercise it for at least 1
hour looking for leaks, loose
connections or components,
and abnormal operating condi-
tions. Correct as necessary.
• •
17. Start and exercise the unit at
full rated load (use a load bank
if the site load is not enough)
for at least 2 hours looking
for leaks, loose connections
or components, and abnormal
operating conditions. Correct as
necessary.
•
18. Change the engine oil.
•
19. Replace the engine oil filter(s).
• •
20. Replace the engine air filter(s).
• •
21. Replace the engine fuel filter(s)
on diesel engine driven units
and re-prime the fuel system.
• •
22. Check the engine spark plugs
on gas engine driven units.
Clean and re-gap orreplace as
necessary.
• •
23. Perform a 5 minute no-load
operational run of the unit
looking for any post service
problems.
• •
24. Return the unit to standby
setup for operation when
required.
• • • •