Filter
Top Products
Problem Possible Cause Solution
25
Problems and Solutions Guide
Vehicle was running but Loose wire or loose connectors Check all wires and connectors. Make sure the battery
suddenly stopped connector is tightly plugged into the motor harness
connector, and that there are no loose wires around the
motors.
Wrong type or improperly installed fuse Make sure that the battery has properly installed
Power Wheels
®
30 amp fuses installed before charging.
For best performance, do not use substitute parts.
Blown fuses Make sure that the fuses in the batteries are in good
condition. Remove the fuse from the battery and make
sure they are not blown. Replace a blown fuse with a
Power Wheels
®
30 amp fuse. For best performance, do not
use substitute parts.
Vehicle is overloaded Make sure you do not overload the vehicle by allowing
more than 1 rider at one time, by exceeding the 65 lbs.
maximum weight capacity, or by towing objects behind the
vehicle. If the vehicle is overloaded, the fuses in the batter-
ies may blow. Remove the fuses from the batteries and
check to see if they have blown. Replace a blown fuse with
a Power Wheels
®
30 amp fuse.
Driving conditions are too stressful Use only on gentle inclines or slopes of 10˚ or less. Extreme
temperatures can also affect run time. If the driving
conditions are too stressful, the fuses in the batteries may
blow. Remove the fuses from the batteries and check to see
if they have blown. Replace a blown fuse with a
Power Wheels
®
30 amp fuse.
Short run time (Less than Undercharged batteries Charge the batteries. New batteries should have been
1 - 3 hours per charge) charged for at least 18 hours before using the vehicle for
the first time. After first-time use, recharge the batteries for
at least 14 hours after each use. Never charge the
batteries longer than 30 hours.
Check all wires and connectors. Make sure the battery
connector is tightly plugged into the charger connector,
and that the charger is plugged into the wall.
Make sure power flow to the wall outlet is “ON”.
Overcharged batteries Do not charge the batteries longer than 30 hours. If you
suspect that your batteries are damaged as a result of
overcharging, contact your local Power Wheels
®
authorized
service center. They can test your batteries for you.
Batteries are old and will not Even with proper care, a rechargeable battery does not
accept full charge last forever. Average battery life is 1 to 3 years depending
on vehicle use and use conditions. For best performance,
do not use substitute parts.
Wrong type or improperly installed fuse Make sure that the batteries have properly installed
Power Wheels
®
30 amp fuses before charging.
For best performance, do not use substitute parts.
Driving conditions are too stressful Use only on gentle inclines or slopes of 10˚ or less. Extreme
temperatures can also affect run time. If the vehicle is over-
loaded, the fuses in the batteries may blow. Remove the
fuses from the batteries and check to see if they have
blown. Replace a blown fuse with a Power Wheels
®
30 amp
fuse.