Filter
Top Products
OPERATION AND SERVICE INFORMATION
Page 21
Owner’s Manual and Service Guide
Read all of manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notes, Cautions and Warnings
LUBRICATION POINTS
Do not use more than three (3) pumps
of grease in any grease fitting at any
one time. Excess grease may cause grease seals to fail or
grease migration into areas that could damage components.
Add no more than two or three pumps of grease to fit-
tings shown (Ref. Fig. 31 on page 21). More than three
pumps in a grease fitting could damage seals allowing
contamination of grease-sensitive components.
BATTERY
To reduce possibility of discharging
battery and leaving insufficient reserve
to start vehicle, do not use accessories excessively while engine
is off.
Failure to promptly charge a discharged battery will shorten its
life span.
Unless equipped with optional high output alternator, the
vehicle uses a charge coil to charge battery. Battery is
charged while engine is running. Do not operate acces-
sory items (such as accessory lights, radios, winch, etc.)
excessively while engine is off. The charge coil is capa-
ble of supplying 20 amps; therefore, operation of all
accessories could result in discharge of battery even
though engine is running.
Discharging and recharging a battery is known as deep
cycling. The battery is not a deep cycle model, but is a
starting battery that is intended to maintain a full charge
from the charging circuit. Multiple deep cycles will result
in premature failure of battery.
If battery becomes discharged, vehicle can be jump
started. See JUMP STARTING on page 22. After starting,
promptly charge battery using a 12 volt charger rated at
10 amps or less and in accordance with all instructions
provided by the manufacturer of charger.
Fig. 30 Fuel Filter
Ref Ffi 1
Fig. 31 Lubrication Points
Ref Lub 5
Slip Joints
& U-Joint
Yokes
View From Underside of Vehicle