Filter
Top Products
67
MAINTENANCE AND LUBRICATION
Periodic Maintenance Schedule
Item Hours/
Miles
Frequency Remarks
Carburetor float
bowl
50 hrs. 6 months Drain bowl periodically and
prior to storage
J Throttle Cable/ETC
Switch
50 hrs. 6 months Inspect; adjust; lubricate;
replace if necessary
L
Choke (enricher)
cable
50 hrs. 6 months Inspect; adjust; lubricate;
replace if necessary
Shift linkage 50 hrs. 6 months Inspect; adjust
J Drive belt 50 hrs. 6 months Inspect; replace as needed
" Steering 50 hrs. 6 months Inspect daily; lubricate
" Front suspension 50 hrs. 6 months Inspect; lubricate; tighten
fasteners
" Rear suspension 50 hrs. 6 months Inspect; tighten fasteners
" Drive chain(s) 50 hrs. 6 months Inspect daily; adjust and lu-
bricate if needed
" Rear axle 50 hrs. 6 months Inspect bearings; lube
L
Spark plug 100 hrs. 12 months Inspect; replace as needed
J
L
Ignition Timing 100 hrs. 12 months Inspect; adjust as needed
J
L
Fuel system 100 hrs. 12 months Check for leaks at tank
cap, lines, fuel valve, filter,
pump and carburetor; re-
place lines every two years
J Fuel filter 100 hrs. 12 months Replace annually
" More often under severe use, such as dirty or wet conditions
L Emission Control System Service (California)
J Dealer service item