Filter
Top Products
7/14/08
35
Section 7: Lubrication and Fluids
4400EX Heavy Duty Off Road Utility Vehicle 720-051M
Table of Contents
Steering & Cargo Lift Cylinder Fluid
!
WARNING
Hydraulic fluid under pressure can penetrate skin. Wear
protective gloves and safety glasses or goggles when working
with hydraulic systems.use a piece of cardboard or wood rather
than hands when searching for hydraulic leaks. If hydraulic
fluid is injected into the skin, it must be surgically removed
within a few hours by a doctor or gangrene may result.
The hydraulic fluid operates the power steering, cargo lift
and hydraulic controlled accessory equipment. For your
safety and the safety of others it is important that the
hydraulic fluid be maintained. If the reservoir is loosing
fluid frequently, have a Land Pride Dealer inspect the
vehicle.
Hydraulic Fluid Maintenance Schedule
• Check fluid reservoir monthly.
• Fill reservoir immediately if low or if hydraulics are
operating poorly.
Hydraulic Fluid Type and Capacity
See also "Section 10: Specifications and Capacities" on
page 40
• Type of fluid: Dextron 3 automatic transmission fluid
• Quantity: 2 quarts. Tank should be 3/4 full when all
accessories are in retracted position.
Hydraulic Fluid Level Check
Refer to Figure 7-10
The fluid reservoir is located on the driver’s side under the
seat. Visually inspect fluid level inside the reservoir.
Remove filler cap and add automatic transmission fluid if
low.
Figure 7-10
Monthly
21361
Grease Type Lubrication
There are several points on the vehicle that require
lubrication. It is important that these points be lubricated
frequently to maintain ease of lever operation and to
ensure long bearing life.
Driveline U-Joints
Refer to Figure 7-11 and Figure7-12
Grease every 100 hours of operation
• Type of Grease: Multipurpose
• Quantity: 3 or 4 pumps of the grease gun. Stop adding
grease if lubricant is emerging through the seals.
Front Drive Line U-Joint
Figure 7-11
Rear Drive Line U-Joint
Figure7-12
100 hrs
21355
21356