Filter
Top Products
Section 6: Maintenance
4400EX Heavy Duty Off Road Utility Vehicle 720-051M
7/14/08
30
Table of Contents
(1) Reservoir should be 3/4 full when all hydraulic accessories are in retract position.
(2) Replace air cleaner pre-cleaner if damaged.
(3) Check tightness after first 2 hours of initial operation and 2 hours after removal for repair and/or replacement.
(4) Replace paper element if extremely dirty or damaged.
(5) Make first oil and filter change after the first month of operation or at 20 hours of operation (whichever comes first).
(6) Service every 100 hours or 6 months (whichever comes first).
(7) Change differential oil ever year or every 400 hours (whichever comes first).
(8) Transmission fluid does not require changing unless contaminated with water. Change immediately if contaminated with water.
(9) Clean spark arrester whenever loss of engine power is noticed or every season (whichever comes first).
(10) Have a Land Pride dealer perform this service every year or every 500 hours (whichever comes first)
Maintenance Schedule
Maintenance Operation Daily
Every
25 Hrs
Every
100
Hrs.
Every
200
Hrs.
Every
6
Mos.
Every
Season
Refer to
Page
Check Engine Oil level X 31
Check Hydraulic Fluid Level (1) X 35
Check Tire Pressure X 23
Check for Fluid Leaks X
Inspect All Nuts and Bolts for Tightness X 22
Check and Clean Area Around Air Intake X 28
Grease Zerk Fittings for rotating surfaces - 2
places
X36
Service Air Cleaner Pre-cleaner Foam
Element(2)
X28
Check Wheel Lug Nuts (Torque 65 to 75 Ft. lbs.)
(3)
X22
Grease Zerk Fittings for bearings - 3 places X 35 & 36
Service Air cleaner Paper Element (4) X 28
Change Engine Oil (5) & (6) X X 32
Change Engine Oil Filter (5) & (6) X X 32
Check Differential Fluid Level (7) X X 33
Check Transmission Fluid Level (8) X X 34
Check Battery Charge and Water Level X 23
Inspect Drum Brakes X
Inspect Parking Brake X
Check Master Cylinder Brake Fluid X 34
Check & Regap Spark Plugs (1.02 mm / .04 in.) X
Check Fuel Line Hoses and Clamps X26
Replace In-line Fuel Filter X26
Clean Battery and Terminals X23
Check Power Steering Belt X27
Clean Spark Arrester (9) X29
Service Bendix starter drive (10) X
Disassemble and clean solenoid shift starter (10) X