Filter
Top Products
Front Shock Absorbers
2005 HUV4213 Gasoline Vehicle Owner’s Manual Page 19
FRONT SHOCK ABSORBERS
The vehicle arrives from the factory with the front coil-over shocks pre-adjusted for optimum vehicle perfor-
mance. We do not recommend adjusting the shock absorbers unless the vehicle will be equipped with a cab
enclosure. In that event, please refer to the cab installation instructions for the shock absorber adjustment pro-
cedure.
LOADING AND UNLOADING
ý WARNING
• Firmly engage park brake before loading vehicle.
• Do not allow riders in the cargo bed.
• Reduce vehicle load and speed when driving up or down slopes or on uneven terrain.
• Do not exceed rated vehicle capacity. Rated capacity is for level surfaces only.
• Overloading can affect vehicle handling or cause component failure, resulting in loss of
control of vehicle and possible severe personal injury or death.
• Do not load tailgate. The tailgate should be in the upright position and latched securely while
the vehicle is in motion.
• To help avoid shifting vehicle load and possibly overturning the vehicle, avoid sudden starts,
sudden stops and abrupt turns. Make sure cargo is well secured.
• Avoid top-heavy loads. The center of gravity of load should never exceed 15 inches (38 cm)
above the bottom of the cargo bed.
• The cargo’s center of gravity may affect handling, steering, and braking of the vehicle. When
the vehicle is loaded, reduce speed and drive slowly in turns.
• Unload cargo bed before raising vehicle with a lift, hoist, or jack.
• Avoid stopping on a hill when loaded. If you must stop on a hill, avoid sudden starts, or rolling
backwards and stopping suddenly. Failure to heed this warning may cause vehicle to
overturn, possibly resulting in severe personal injury.
• Reduce speed and avoid sudden stops when backing up. Failure to do so may cause the
vehicle to overturn or flip over backwards.
Center and secure cargo as far forward as possible in the cargo bed. Do not overload the vehicle. See the fol-
lowing chart for vehicle capacities.
Maximum payload capacity must be reduced accordingly when any option or accessory is installed on the
vehicle. See following NOTE.
NOTE: A standard HUV4213 vehicle with a cab accessory weighing 235 lb. (107 kg) must reduce its max-
imum payload capacity by 235 lb. (107 kg) to 565 lb. (256 kg).
HUV4213
Maximum payload capacity
(Cargo bed load plus gross trailer weight)
800 lb. (363 kg)
Maximum vehicle capacity
(Cargo load, passengers, plus gross trailer weight)
1200 lb. (545 kg)
Maximum gross vehicle weight
(Fully loaded vehicle, including accessories)
2381 lb. (1080 kg)
Maximum passenger capacity
(Operator and passenger)
400 lb. (181 kg)
Trailer tongue weight 150 lb. force (667 N)