Filter
Top Products
11
Vehicle does not run
Vehicle was running but
suddenly stopped
Short run time (less than
30 minutes per charge)
Vehicle runs sluggishly
TROUBLESHOOTING GUIDE
Problem Possible Cause Solution
Undercharged battery
Charger is not working
Loose wires or connectors
Burned-out fuse
Motor or electrical switch damage
Undercharged battery
Battery is old and will not accept full
charge
Brakes are not adjusted properly
Driving conditions are too stressful
Tires are not properly inflated
Vehicle is overloaded
Charge the battery. A new battery should have been charged for at
least 12 hours before using the vehicle for the first time and up to 8
hours after each subsequent use.
Check all connectors. Make sure the charger connector is tightly
plugged into the charging port, and that the charger is plugged into
the wall.
Make sure power flow to the wall outlet is on.
You may check to see if your charger is working by using a volt meter or
asking your local Razor authorized service center to test your charger
for you.
Check all wires and connectors to make sure they are tight.
The fuse will burn out and automatically shut off the power if the
motor is overloaded.
An excessive overload, such as too heavy a rider or too steep a hill,
could cause the motor to overheat. Replace the fuse with a new one
of equal amperage. Correct the conditions that caused the fuse to burn
out and avoid repeatedly burning out fuse.
Contact your local Razor authorized service center for diagnosis and
repair.
Charge the battery. A new battery should have been charged for at
least 12 hours before using the vehicle for the first time and up to 8
hours after each subsequent use.
Check all wires and connectors. Make sure the battery connector is
tightly plugged into the charger connector, and that the charger is
plugged into the wall.
Make sure power flow to the wall outlet is on.
Even with proper care, a rechargeable battery does not last forever.
Average battery life is 1 to 2 years depending on vehicle use and
conditions. Replace only with a Razor replacement battery.
Refer to brake adjustment instructions on page 5 of this manual.
Use only on solid, flat clean and dry surfaces such as pavement or
level ground.
The tires are inflated when shipped, but they invariably will lose some
pressure between the point of manufacturing and your purchase. Refer
to instructions on page 4 and 5 of this manual to properly inflate tires.
Make sure you do not overload the vehicle by allowing more than
one rider at one time, exceeding the maximum weight limit, going up
too steep a hill or towing objects behind the vehicle. If the vehicle is
overheated, the temperature circuit protector will slow motor down
and if the condition continues, will shut off power to the motor. Correct
the driving conditions that caused the overheating, wait 5-10 minutes
and then resume riding. Avoid repeatedly overheating the unit.