Filter
Top Products
The following abbreviations are used to represent values for Control Module Pin-Out data
I Input SG Sensor Ground S SCP Network V Voltage (DC)
O Output A ACP Network D Serial and Encoded Data Hz Frequency
SS Sensor Supply V C CAN (Network) B+ Battery Voltage kHz Frequency x 1000
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation. THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components
connected and fitted. “Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE: September 2000
Fig. 21.1
COMPONENTS
Component Connector / Type / Color Location / Access
ABS / TRACTION CONTROL CONTROL MODULE LF27 / 25-WAY AMP / FORD / BLACK ENGINE COMPARTMENT / BEHIND LH HEADLAMP ASSEMBLY
BODY PROCESSOR MODULE FC15 / 14-WAY AMP EEEC / GREY BULKHEAD / BEHIND GLOVE BOX
DATA LINK CONNECTOR CC6 / 16-WAY AMP (OBD2) / BLACK TRANSMISSION TUNNEL
DOOR CONTROL MODULE – DRIVER DD10 / 22-WAY FORD 2.8 TIMER / BLUE DOOR CASING / TRIM PANEL
DD11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR CONTROL MODULE – DRIVER REAR RD10 / 22-WAY FORD 2.8 TIMER / BLUE DOOR CASING / TRIM PANEL
RD11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR CONTROL MODULE – PASSENGER PD10 / 22-WAY FORD 2.8 TIMER / BLUE DOOR CASING / TRIM PANEL
PD11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR CONTROL MODULE – PASSENGER REAR RP10 / 22-WAY FORD 2.8 TIMER / BLUE DOOR CASING / TRIM PANEL
RP11 / 22-WAY FORD 2.8 TIMER / BLACK
ENGINE CONTROL MODULE EM80 / 31-WAY AMP 403 / NATURAL ENGINE COMPARTMENT / CONTROL MODULE ENCLOSURE
EM81 / 24-WAY AMP 403 / NATURAL
EM82 / 17-WAY AMP 403 / NATURAL
EM83 / 28-WAY AMP 403 / NATURAL
EM84 / 22-WAY AMP 403 / NATURAL
EM85 / 12-WAY MULTILOCK 070 / WHITE
GEAR SELECTOR ILLUMINATION MODULE CC14 / 10-WAY MULTILOCK 070 / WHITE CENTER CONSOLE ASSEMBLY
INSTRUMENT PACK FC24 / 26-WAY AMP MICRO QUAD LOCK / BLACK FASCIA
FC25 / 26-WAY AMP MICRO QUAD LOCK / YELLOW
SEAT CONTROL MODULE – DRIVER SD1 / 16-WAY FORD 2.8 TIMER / BLACK DRIVER SEAT / UNDER
SD2 / 26-WAY FORD IDC / BLACK
SD3 / 10-WAY FORD 2.8 TIMER / BLACK
SEAT CONTROL MODULE – PASSENGER SP1 / 16-WAY FORD 2.8 TIMER / BLACK PASSENGER SEAT / UNDER
SP3 / 10-WAY FORD 2.8 TIMER / BLACK
SPLICE HEADER – CA222 CA222 / 20-WAY SUMITOMO SPLICE HEADER / GREY RH HEELBOARD / HEELBOARD COVER
SPLICE HEADER – CA223 CA223 / 20-WAY SUMITOMO SPLICE HEADER / BLACK RH HEELBOARD / HEELBOARD COVER
TRANSMISSION CONTROL MODULE: AJ27 N/A EM7 / 88-WAY BOSCH / BLACK ENGINE COMPARTMENT / CONTROL MODULE ENCLOSURE
TRANSMISSION CONTROL MODULE: AJ27 SC EM61 / 18-WAY AMP JUNIOR POWER TIMER / BLACK ENGINE COMPARTMENT / CONTROL MODULE ENCLOSURE
EM62 / 14-WAY AMP JUNIOR POWER TIMER / BLACK
HARNESS-TO-HARNESS CONNECTORS
Connector Type / Color Location / Access
BT4 54-WAY THROUGH PANEL / GREY BELOW PARCEL SHELF / TRUNK / REAR BULKHEAD / RH SIDE
CA8 20-WAY MULTILOCK 070 / WHITE DRIVER ‘A’ POST / DOOR HARNESS GAITER
CA11 20-WAY MULTILOCK 070 / WHITE PASSENGER ‘A’ POST / DOOR HARNESS GAITER
CA19 20-WAY MULTILOCK 070 / YELLOW LH ‘A’ POST CONNECTOR MOUNTING BRACKET / LOWER ‘A’ POST FINISHER
CA23 10-WAY MULTILOCK 070 / WHITE BELOW DRIVER SEAT
CA27 10-WAY MULTILOCK 070 / WHITE BELOW PASSENGER SEAT
CA45 6-WAY MULTILOCK 070 / WHITE PASSENGER ‘B/C’ POST / DOOR HARNESS GAITER
CA46 4-WAY MULTILOCK 070 / WHITE DRIVER ‘B/C’ POST / DOOR HARNESS GAITER
EM1 12-WAY AUGAT 1.6 / BLACK ENGINE COMPARTMENT / ADJACENT TO ABS PUMP
EM2 20-WAY MULTILOCK 070 / GREY PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
FC1 54-WAY THROUGH PANEL CONNECTOR / GREY BELOW PASSENGER SIDE AIR VENT / GLOVE BOX ASSEMBLY
FC7 20-WAY MULTILOCK 070 / YELLOW ABOVE DIMMER MODULE / COIN TRAY
FC11 18-WAY MULTILOCK 070 / WHITE ABOVE DIMMER MODULE / COIN TRAY
GROUNDS
Ground Location / Type
CC3L EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
NOTE: Refer to the Appendix at the rear of this book for CAN and SCP Network messages.