Filter
Top Products
The following abbreviations are used to represent values for Control Module Pin-Out data
I Input D Serial and Encoded Data B+ Battery Voltage kHz Frequency x 1000
O Output C CAN (Network) V Voltage (DC) ms Milliseconds
SG Signal Ground S SCP Network Hz Frequency mV Millivolts
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation. THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all
components connected and fitted. “Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE: October 1999
Fig. 14.1
COMPONENTS
Component Connector / Type / Color Location / Access
BODY PROCESSOR MODULE FC15 / 14-WAY AMP EEEC / GREY BULKHEAD / BEHIND GLOVE BOX
FUSE BOX – ENGINE COMPARTMENT LF5 / 10-WAY U.T.A. FUSE BOX / NATURAL ENGINE COMPARTMENT / LH FRONT
LF6 / 10-WAY U.T.A. FUSE BOX / BLACK
LF7 / 10-WAY U.T.A. FUSE BOX / GREEN
LF8 / 10-WAY U.T.A. FUSE BOX / BLUE
ST19 / EYELET
INTERIOR REAR VIEW MIRROR CA55 / 8-WAY MULTILOCK 070 / YELLOW WINDSHIELD / IN FRONT OF ROOF CONSOLE
LIGHTING STALK (COLUMN SWITCHGEAR) SC2 / 10-WAY MULTILOCK 070 / YELLOW COLUMN SWITCHGEAR HARNESS /
ADJACENT TO STEERING COLUMN MOTOR
POWER WASH PUMP LF43 / 2-WAY REINSHAGEN / VOLKSWAGEN / BLACK RIGHT FRONT QUARTER PANEL / WASHER FLUID CONTAINER
RAIN SENSING MODULE EM72 / 12-WAY AMP ML42 / BLACK ENGINE COMPARTMENT / CONTROL MODULE ENCLOSURE
RAIN SENSOR NO CODES / 3-WAY AMP MICRO QUAD LOCK / BLACK BEHIND INTERIOR REAR VIEW MIRROR
WASH / WIPE STALK (COLUMN SWITCHGEAR) SC1 / 12-WAY MULTILOCK 070 / WHITE COLUMN SWITCHGEAR HARNESS /
ADJACENT TO STEERING COLUMN MOTOR
WINDSHIELD WASH PUMP AND FLUID LEVEL SENSOR LF44 / 3-WAY AUGAT 1.6 / BLACK RIGHT FRONT QUARTER PANEL / WASHER FLUID CONTAINER
WIPER MOTOR EM33 / 4-WAY AUGAT 1.6 / BLACK ENGINE COMPARTMENT / BULKHEAD
RELAYS
Relay Case Color Connector / Color Location / Access
WIPER RUN / STOP RELAY BLACK LF11 / BLACK ENGINE COMPARTMENT FRONT RELAYS / ENGINE COMPARTMENT
WIPER FAST / SLOW RELAY BLACK LF11 / BLACK ENGINE COMPARTMENT FRONT RELAYS / ENGINE COMPARTMENT
POWERWASH RELAY BROWN BUS RELAY #4, ENGINE COMPARTMENT FUSE BOX / ENGINE COMPARTMENT
HARNESS-TO-HARNESS CONNECTORS
Connector Type / Color Location / Access
EM3 18-WAY MULTILOCK 070 / WHITE PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
EM51 12-WAY AUGAT 1.6 / GREY ENGINE COMPARTMENT / ADJACENT TO ABS PUMP
FC5 54-WAY THROUGH PANEL CONNECTOR / GREY BELOW DRIVER SIDE AIR VENT / COIN TRAY
LF3 54-WAY THROUGH PANEL CONNECTOR / GREY LH ‘A’ POST / LOWER ‘A’ POST FINISHER
GROUNDS
Ground Location / Type
EM8L EYELET (PAIR) – EMS LH GROUND STUD
EM17 EYELET (SINGLE) – EMS BULKHEAD GROUND STUD
FC17R EYELET (PAIR) – EMS BULKHEAD GROUND STUD
LF18R EYELET (PAIR) – LH FORWARD GROUND STUD
LF19L EYELET (PAIR) – RH FORWARD GROUND STUD
FOR CONTROL MODULE PIN OUT INFORMATION, UNFOLD PAGE TO LEFT.
CONTROL MODULE PIN OUT INFORMATION
BODY PROCESSOR MODULE
Pin Description Active Inactive
I FC15-6 WASHER FLUID LEVEL SENSOR GROUND (FULL) B+ (EMPTY)
I FC15-9 VARIABLE INTERMITTENT WIPE REQUEST
I FC15-15 IGNITION SWITCHED GROUND GROUND B+
I FC15-16 SIDE LAMP REQUEST GROUND B+
O FC15-18 POWER WASH RELAY ACTIVATE GROUND B+
O FC15-19 WIPER FAST / SLOW RELAY ACTIVATE GROUND (FAST) B+ (SLOW)
O FC15-26 WINDSHIELD WASHER PUMP ACTIVATE B+ GROUND
I FC15-34 FAST WIPE SPEED REQUEST GROUND B+
I FC15-37 PROGRAMMED WASH REQUEST GROUND (MOMENTARY) B+
O FC15-43 WIPER RUN / STOP RELAY ACTIVATE GROUND B+
I FC15-60 WIPER MOTOR PARK SWITCH STATUS GROUND (PARKED) B+ (NOT PARKED)
I FC15-80 BATTERY SUPPLY VOLTAGE B+ B+
I FC15-94 SLOW / FLICK WIPE REQUEST GROUND B+
I FC15-104 BATTERY SUPPLY VOLTAGE B+ B+