Filter
Top Products
ESCAPE HYBRID OR MARINER HYBRID COMPONENTS IDENTIFICATION
Please note the location of the following unique Hybrid components. Refer to the
vehicle component location graphic on the following page.
Component Location Description
1 Rear Inertia Switch Passenger side. Behind right
rea
r trim panel
The
inertia switch disconnects high
voltage
and fuel in a collision -see
page
8.
2 High Voltage Service
Di
sconnect Switch
The
High Voltage Service
Disconnect
Switch is located
on
the top, passenger side, of
the
high voltage battery. It has
a molded plastic handle that
is
safety orange in color for
easy
identification. The high
voltage
battery is located
belo
w the floor carpet in the
rea
r of the vehicle.
Provide
s high voltage battery
disconnect
for service. It has a
molded
plastic handle that is safety
orange
in color for easy identification,
3 High Voltage Battery
(300+ volts)
Rea
r of vehicle – below
carpet
Sealed Nickel-Metal Hydride – 300 +
volts
.
4 High Voltage Wiring Orange wire – Runs along the
bottom
of the vehicle between
the
high voltage battery and
the
ECVT (Electronically
Controlled
Continuously
Variabl
e Transmission). Also
connects ECVT to the DC to
DC converter
Con
nects high voltage battery to
ECVT
Connects ECVT to DC to DC
conve
rter. All high voltage wires and
con
nectors will be orange.
5 12 Volt Battery Driver side of vehicle. Under
hood
– front
Provide
s 12 volt power to the vehicle
– Traditional lead /acid battery.
6 ECVT (Electronically
Controlled
Continuously
Variable
Tra
nsmission )
Same
position as a traditional
transaxle
Contains the traction motor,
generato
r motor and hybrid
electronics.
7 DC/DC Converter Passenger Side . Under hood.
Located
in front of the shock
towe
r
Provides 12 volt power to charge the
battery
and run 12V electrical
accessories
8 Front Inertia Switch Passenger compartment,
passenge
r side, front seat,
low
er kick panel
The
inertia switch disconnects the
high
voltage circuit and the electrical
circuit
to the gasoline fuel pump in a
coll
ision
NOTE: All High Voltage wires and harnesses are wrapped in orange-colored insulation.
FCS-14265-05
6
2006/07 Escape Hybrid, Mariner Hybrid Emergency Response Guide, 08/2006