Sioux Tools 6056 Automobile User Manual


  Open as PDF
of 28
 
Page 10
MIXER SETUP
Checkforproperassembly,adjustment,andlubrication.Checktoseethatthereisadequateoilintheoilbath.If
powerchuteisused,oiltherollerchains.Checkallboltandsetscrewsaretight.
Besureallshieldsareproperlyinplace.
Checkforandremoveanyforeignobjectsinthemixerhopperanddischargeopening.
Checktoseethatdrainplugsareinstalledandthedoorisclosed.
Besurenooneisinsidethemixer.
• Test run the mixer.
•Makesuremixerisempty,thenstartthemixer.
•RunforatleastveminutesatratedPTORPM.
•Raiseandlowerthedoorandoperatethechute/slidetrayseveraltimes.
•Disengagethemixerandturnoffthetractorengineandremovedriveline.
•Checkthemixerdrivecomponentstobesuretheyarenotabnormallyhot.
If any of these items are not running as indicated, immediately repair or contact your service
representative.
•
•
•
•
•
MIXER RUN-IN
Toadjusttheheightofthepowerchute,changethelengthofthelinkchainsonthesidesofthechute.Forbest
performance,theunloadingheightshouldbesetatthelowestheightpossible.Thedischargetip-offonthepower
chuteshouldbeadjustedforcorrectmagnetanddischargeangle.Removeorloosentheupperbolts,pivotthe
tipofftothedesiredanglesandreinstallorretightenallbolts.
•
POWER CHUTE ADJUSTMENT (OPTIONAL)
Toavoidpersonalinjury:Thehopperoormaybeslipperyandtheaugercanspinunexpectedlywhenstepped
on.Usecautionwhensteppingorstandinginsidetheunit,placeaprotectivecoverovertheaugerknives
whenworkinsidetheboxisrequired.
MIXER OPERATION
AlwaysrefertoEquipmentSafetyGuidelines&BeforeOperationsectionsofthismanualbeforeoperatingthismixer.
TheTurbo-MaxMixerwasdesignedforblendingdairyandbeefrations.Mostcommonlyusedingredients,including
limitedamountsofdrystemhay,canbemixedquicklyanduniformlyinthismixer.Ifyouhavequestionsregarding
yourfeedrationorhaveotherapplications,pleasecontactSiouxAutomationCenter,Inc.
TheTurbo-MaxMixermixingperformancecanvarygreatlyaccordingtothedifferencesinmaterials,loadingse-
quence,mixingspeed,andunloadingmethods.
•
•
GENERAL
Whenthemixerisinoperationithasmanymovingpartswhichcouldcausesevereinjuryordeathtopersons
comingincontactwiththeseparts.Tohelpavoidseriousaccidents,pleasereadandunderstandthismanual.
•
SAFETY
 previous next