Filter
Top Products
(c) For warranty repairs, the engine must be presented to a Kohler Co. service center as soon as a problem exists.
Call 1-800-544-2444 or access our web site at: www.kohlerengines.com, for the names of the nearest service centers. The warranty
repairs should be completed in a reasonable amount of time, not to exceed 30 days.
If you have any questions regarding warranty rights and responsibilities, you should contact Kohler Co. at 1-920-457-4441 and ask for an
Engine Service representative.
COVERAGE
Kohler Co. warrants to the ultimate purchaser and each subsequent purchaser that the engine will be designed, built and equipped, at the
time of sale, to meet all applicable regulations. Kohler Co. also warrants to the initial purchaser and each subsequent purchaser, that the
engine is free from defects in materials and workmanship which cause the engine to fail to conform with applicable regulations for a period
of two years.
Engines produced in 1995 or later are warranted for two years in California. For 1997 and later model years, EPA requires manufacturers to
warrant engines for two years in all other states. These warranty periods will begin on the date the engine is purchased by the initial
purchaser. If any emission related part on the engine is defective, the part will be replaced by Kohler Co. at no cost to the owner. Kohler
Co. is liable for damages to other engine components caused by the failure of a warranted part still under warranty.
Kohler Co. shall remedy warranty defects at any authorized Kohler Co. engine dealer or warranty station. Warranty repair work done at an
authorized dealer or warranty station shall be free of charge to the owner if such work determines that a warranted part is defective.
Listed below are the parts covered by the Federal and California Emission Control Systems Warranty. Some parts listed below may require
scheduled maintenance and are warranted up to the first scheduled replacement point for that part. The warranted parts are:
• Oxygen sensor (if equipped) • Ignition module(s) with high tension lead
• Intake manifold (if equipped) • Gaseous fuel regulator (if equipped)
• Exhaust manifold (if equipped) • Electronic control unit (if equipped)
• Catalytic muffler (if equipped) • Carburetor or fuel injection system
• Fuel metering valve (if equipped) • Fuel lines (if equipped)
• Spark advance module (if equipped) • Air filter, fuel filter, and spark plugs (only
• Crankcase breather to first scheduled replacement point)
LIMITATIONS
This Emission Control Systems Warranty shall not cover any of the following:
(a) repair or replacement required because of misuse or neglect, improper maintenance, repairs improperly performed or replacements
not conforming to Kohler Co. specifications that adversely affect performance and/or durability and alterations or modifications not
recommended or approved in writing by Kohler Co.,
(b) replacement of parts and other services and adjustments necessary for required maintenance at and after the first scheduled
replacement point,
(c) consequential damages such as loss of time, inconvenience, loss of use of the engine or equipment, etc.,
(d) diagnosis and inspection fees that do not result in eligible warranty service being performed, and
(e) any add-on or modified part, or malfunction of authorized parts due to the use of add-on or modified parts.
MAINTENANCE AND REPAIR REQUIREMENTS
The owner is responsible for the proper use and maintenance of the engine. Kohler Co. recommends that all receipts and records covering
the performance of regular maintenance be retained in case questions arise. If the engine is resold during the warranty period, the
maintenance records should be transferred to each subsequent owner. Kohler Co. reserves the right to deny warranty coverage if the
engine has not been properly maintained; however, Kohler Co. may not deny warranty repairs solely because of the lack of repair
maintenance or failure to keep maintenance records.
Normal maintenance, replacement or repair of emission control devices and systems may be performed by any repair establishment or
individual; however, warranty repairs must be performed by a Kohler authorized service center. Any replacement part or service that is
equivalent in performance and durability may be used in non-warranty maintenance or repairs, and shall not reduce the warranty obligations
of the engine manufacturer.
LITHO IN U.S.A.
FORM NO.: TP-2472-I
ISSUED: 12/94
REVISED: 12/01
MAILED:
ENGINE DIVISION, KOHLER CO., KOHLER, WISCONSIN 53044
FOR SALES AND SERVICE INFORMATION
IN U.S. AND CANADA, CALL
1-800-544-2444