Filter
Top Products
60
• Power unit door must be left open while charging.
• Check that line voltage is same as rated voltage of charger.
• Ammeter will show a high rate of charge if batteries are low, and
will drop to a low rate as the batteries become fully charged.
• Extension cord, if used, must have correct plugs and meet
minimum AWG size on chart.
To avoid damage to truck:
Specific Gravity
Charge Time % of Charge
RECOMMENDED CHARGING TIME
100%
75%
50%
25%
1.260 0
1.250 4
1.230 6
1.210 8
1.190 10
1.170 12
1.150 14
1.130 16
CAUTI NO
AC Input Rating, Amps.
AWG Cord Size
Equal to or
greater than
MINIMUM AWG FOR EXTENSION CORD SIZE TO
BATTERY CHARGER
but less
than
0
2
2
3
3
4
4
5
18 18 16
18 16 14
18 16 14
16 14 12
Length of Cord
15m(50') 30m(100') 45m(150')
04
It’s the law, you must be trained
and certified to operate this truck.
(OSHA § 1910.178, Rev. 1999)
* Additional copies of the Operators Manual and Truck
Labels can be obtained from Crown Equipment Corp.,
New Bremen, OH 45869 U.S.A.
You or people around you could be
seriously injured or even killed if you
don't use this truck correctly.
Obey all warnings and instructions on the truck
and in the operator manual*.
Inspect your truck before starting work, make
sure it is in good working order.
WARNI GN
Warning Labels 30
Warning Labels
EACH WARNING LABEL
ON YOUR TRUCK IS IMPORTANT
Read and obey all of them to protect
yourself and others.
All rights reserved under International
and Pan American copyright conventions
Copyright 1997 Crown Equipment Corp.
36
Riding on this
truck could
cause serious
injury.
No Riding.
WARNI GN
20
Batteries can produce explosive gas. Do not
smoke, use open flame, or create an arc or sparks
near this battery. Ventilate well when in an enclosed
area and when charging.
This battery contains Sulfuric Acid which causes
severe burns. Do not get in eyes, on skin, or clothing.
In case of contact, flush immediately and thoroughly
with water. Get medical attention if your eyes are
affected.
D
A
N
G
E
R
29 Notes
Notes