Volvo 240 Automobile User Manual


 
1987 Volvo 240
Minor stone chips and scratches
Material:
Rust remover
Primer-brush-on type
Surface finish - brush-on type
Penknife or similar
Brush
Note: When touching-up the car, it should be clean and dry. The surface temperature should be above
60°F(+15°C).
Scars on the surface
(where the paint has not been completely penetrated). Repairs can be made directly after light scraping
to remove dirt.
Deep scars (down to the bare metal)
If the stone chip has penetrated down to the metal, proceed as follows:
1 Scrape or sand the damaged surface lightly and break the edges of the scar.
Apply the rust remover. (avoid contact with eyes and skin!). Wait a few minutes and then rinse carefully
with water and wipe dry.
2 Thoroughly mix the primer and apply it with small brush.
file:///K|/ownersdocs/1987/1987_240/87240_03c.htm (3 of 11)12/30/2006 7:53:32 AM