Razor RED 15555-RD Motorcycle User Manual


 
9
Vehicle does not run
Vehicle was running but
suddenly stopped
Short run time (less
than 30 minutes per
charge)
Vehicle runs sluggishly
Problem Possible Cause
Solution
Undercharged battery
Charger is not working
Loose wires or connectors
Burned out fuse
Motor or electrical switch damage
Undercharged battery
Battery is old and will not
accept full
charge
Brakes are not adjusted properly
Driving conditions are too stressful
Tires are not properly infl ated
Vehicle is overloaded
Brake rotor is dragging on pads
(Rebellion Electric Chopper only)
B
rakes are not adjusted properly
Charge the battery. A new battery should have been charged for at
least 12 hours before using the vehicle for the fi rst time and up to 8
hours after each subsequent use.
Check all connectors. Make sure the charger connector is tightly
plugged into the charging port, and that the charger is plugged into
the wall.
Make sure power fl ow to the wall outlet is on.
You may check to see if your charger is working by using a volt meter
or asking your local Razor authorized service center to test your
charger for you.
Check all wires and connectors to make sure they are tight.
The fuse will burn out and automatically shut off the power if the
motor is ove
rloaded.
An excessive overload, such as too heavy a rider or too steep a hill,
could cause the motor to overheat. Replace the fuse with a new one
of equal amperage. Correct the conditions that caused to fuse to burn
out and avoid repeatedly burning out fuse.
Contact your local Razor authorized service center for d
iagnosis and
r
epa
ir.
Charge the battery. A new battery should have been charged for at
least 12 hours before using the vehicle for the fi rst time and up to 8
hours after each subsequent use.
Check all wires and connectors. Make sure the battery connector is
tightly plugged into the charger connector, and that the charger is
plugged into
the wall.
Make sure power fl ow to the wall outlet is on.
Even with proper care, a rechargeable battery does not last forever.
Average battery life is 1 to 2 years depending on vehicle use and
conditions. Replace only with a Razor replacement battery.
Refer to adjusting the brakes instructions on page 4 to properly
adjust brakes.
Use only on solid, fl at, clean and dry surfaces such as pavement or
level ground.
The tires are infl ated when shipped, but they invariably will lose some
pressure between the point of manufacturing and your purchase.
Refer to instructions on page 5 of this manual to properly infl ate tires.
Make sure you do not overload the vehicle by allowing more than
one rider at one time, exceeding the 220 lb. maximum weight limit,
going up a hill or towing objects behind the vehicle. If the vehicle is
overloaded, the circuit breaker may trip and shut off power to the
motor. Correct the driving conditions that caused the overload, wait
a few seconds, and then push the breaker to reset the circuit. Avoid
repeatedly tripping the circuit breaker.
Use your fi ngers to twist the calliper adjuster in either direction until
rotor is centered between pads
.
Refer to adjusting the brakes instructions on page 4 to properly
adjust brakes.
TROUBLESHOOTING GUIDE