Filter
Top Products
TROUBLESHOOTING 85
Faults Possible cause Measure
Engine turns but does not start. Water in carburetor or jets blocked ದ Clean carburetor.
Engine has no idle. Idling jet blocked ದ Clean carburetor.
Adjusting screws on carburetor distorted ದ Have the carburetor adjusted.
Spark plug defective ದ Change spark plug.
Ignition system defective ದ Have ignition system checked.
Engine does not speed up. Carburetor running over because float
needle dirty or worn
ದ Have carburetor checked.
Loose carburetor jets ದ Have carburetor checked.
Electronic ignition adjustment defective ದ Have ignition system checked.
Engine has too little power. Fuel feed interrupted ದ Check tank vent.
ದ Clean fuel tap.
ದ Clean carburetor.
Air filter very dirty ದ Clean the air filter. ( P. 75)
Exhaust system leaky, deformed or too lit-
tle glass fiber yarn filling in main silencer
ದ Check exhaust system for damage.
ದ Change glass fiber yarn filling of main
silencer.
Valve clearance too little ದ Have valve clearance adjusted.
Electronic ignition adjustment defective ದ Have ignition system checked.
Engine stalls or is popping into the carbu-
retor
Lack of fuel ದ Clean and check the fuel system and
carburetor.
Engine takes in bad air ದ Check rubber sleeves and carburetor
for tightness.
Engine overheats. Too little coolant in cooling system ದ Check the cooling system for leakage.
ದ Check the coolant level. ( P. 72)
Too little air stream ದ Switch off engine when standing.
Radiator fins very dirty ದ Clean radiator fins.
Foam formation in cooling system ದ Drain the coolant. ( P. 72)
ದ Refill the coolant. ( P. 73)
Bent radiator hose ದ Replace the radiator hose.
Thermostat defective ದ Have thermostat removed and checked.
Specification
Opening temperature: 70b°C (158b°F)
Defect in radiator fan system
(EXC-RbSIXbDAYS, XCR-WbZA)
ದ Have the radiator fan system checked.
High oil consumption Engine vent hose bent ದ Route the vent hose without bends or
replace it if necessary.
Engine
oil level too high ದ Check the engine oil level. ( P. 79)
Engine oil too thin (low viscosity) ದ Change the engine oil and oil filter and
clean the engine oil screen. ( P. 79)
Battery discharged Battery is not charged by generator ದ Check electrical system.
Speedometer values deleted (time, stop
watch, lap times)
The battery in the speedometer ist empty. ದ Change the battery in the speedometer.