Allstar Products Group RS4000 Automobile Accessories User Manual


 
24
c.p. Allstar Corporation
Downingtown, PA 19335
This Gate Operator is built in the USA in accordance with
requirements of Underwriters' Laboratories Standard UL-325,
Fourth Edition as amended March 1, 2000.
P/N 110138 Rev. E December 2003
PHYSICAL
PAD:
16” x 24” x 3” Elevation or 4 x 4 Post
OVERHEAD CLEARANCE:
Minimum 12”
UNIT SIZE:
19”W x 14-1/2”L x 11”H
COVER:
One-Piece Molded Polyethylene with no
SHIPPING WEIGHT:
51 lbs.
PRIMARY VOLTAGE:
115 VAC, 60 Hz, 1P
ELECTRICAL SOURCE:
One 3-Wire 15 Amp Service
CONTROL VOLTAGE:
5VDC
RADIO RECEIVER POWER:
24VAC
MOTOR:
1/2 HP 5.0 AMP PSC
AUTO TIMER-TO-CLOSE:
Adjustable 5-30 Seconds
ELECTRICAL
DRIVE
DRIVE SYSTEM:
60:1 Via V-Belt, Motor Drive, Gear
FINAL SPEED:
3.3 RPM
OUTPUT SHAFT:
1” Diameter from bottom of chassis
LIMITS:
Independent Open/Close; Radial
Swing Switches
MAX. GATE WEIGHT:
300 lbs.
MAX. GATE WIDTH:
16 ft.
MAX. CYCLES PER HOUR:
10
SWING:
Maximum Rotation 105°
GATE SPEED:
Approx. 7 Seconds to Open 90°
CAPACITIES
Specifications subject to change without notice. Consult the factory.
Manufacturer’s Limited Warranty
Allstar warrants its gate operators to be free from defect in material and workmanship for a period of five (5) years from the date of purchase
for single family home use and three (3) years from the date of purchase for multi-family and commercial use. This warranty covers all
components except the electronic circuit boards which are warranted for three (3) years from the date of purchase for single family home use
and two (2) years from the date of purchase for multi-family and commercial use. To obtain service contact your dealer.
To obtain service under this warranty the buyer must obtain authorization instructions for the return of any goods from Allstar before
returning the goods. The goods must be returned with complete identification, with copy of proof-of-purchase, freight prepaid and in
accordance with Allstar’s instructions or they will not be accepted. In no event will Allstar be responsible for goods returned without proper
authorization or identification.
Goods returned to Allstar for warranty repair within the warranty period, which upon receipt by Allstar are confirmed to be defective and
covered by this limited warranty, will be repaired or replaced at Allstar’s sole option, at no cost and returned pre-paid. Defective parts will be
repaired or replaced with new or factory rebuilt parts at Allstar’s sole option.
This limited warranty does not cover non-defect damage, damage caused by unreasonable use, damage caused by improper installation or
care, vandalism or lightning, fire or excessive heat, flood or other acts of God (including, but not limited to misuse, abuse or alterations,
failure to provide reasonable and necessary maintenance), labor charges for dismantling or reinstalling a repaired or replaced unit, or
replacement batteries.
These warranties are in lieu of all other warranties, either expressed or implied. All implied warranties of merchantability and/or fitness for a
particular purpose are hereby disclaimed and excluded. Under no circumstances shall Allstar be liable for consequential, incidental or special
damages arising in connection with the use or inability to use this product. In no event shall Allstar’s liability for breach of warranty, breach
of contract, negligence or strict liability exceed the cost of the product covered hereby. No person is authorized to assume for Allstar any
other liability in connection with the sale of this product.
This warranty gives you specific legal rights. You may also have other rights which vary from state to state. Warranty effective after August
1st, 2000.
TECHNICAL SPECIFICATIONS